Abstract:The gasification behavior of agriculture waste was investigated using a Top-lit Up Draft (TLUD) fixed-bed gasifier system which consists of four subsystems (gasifier reaction system, temperature monitor system, tar sampling system, and gas measurement system), in an attempt to find out the influence of air flow on the gasifier’s temperature distribution, gas component, and heating value, and discuss the gasification mechanism of biomass. In the study, peanut shells and rice husks were chosen as experiment material. The reactor is made fromФ219 mm×6 mm stainless steel pipe with length of 800 mm. After the reactor filled up with sample materials (about 3.5 kg), a certain amount of air (range from 2.5 m3/h to 4.0 m3/h) was pumped in at the bottom, and the sample was lit at the top. The temperature was then tested by a temperature monitoring system, and the gas product was detected by a Gasboard-3100P-type multi-component portable infrared gas analyzer (Quartet Photoelectric Technology Co., Ltd. Wuhan, China), and the tar was collected by a tar sampling system. From the results of the investigation, the gasification process lasted about 100 min, and was divided into two stages. First, the main reaction was biomass drying, volatile releasing, and char gasification, and the main gas products were CO2, CO, H2, and CH4. About 50 min later, it went into the second stage, and the oxidization of solid char residue played a major role in the gasifier with a large amount of CO production. Throughout the whole reaction, the heating value of gas products was a minimum of 3 MJ/m3, and the evolution of the gasfier temperature profile was very similar with that of wave propagation. During the first stage of gasification, the maximum temperature of the gasifier was 730℃;when it switched into the second stage, the main reaction occurred at the bottom, and the max temperature would rise up to 1000℃. The airflow rate can be converted to the Air/Fuel equivalence ratio (ER), the most important aspect of gasifier operation. ER had great influence on biomass gasification property, and higher ER was favorable for the enhancing of gas yield, however, it had different effects on the releasing of flammable gas (CO and H2). The optimum gasfication condition was achieved when ER is 0.31 and 0.35 for peanut shell and rice husk, respectively, and the tar content of gas is very low (as low as 0.25g/m3 and 0.49g/m3, respectively). This study would be helpful to the design and operation of TLUD fixed-bed gasifiers.

Numerical and experimental investigation on the thermochemical gasification potential of Cocoa pod husk (Theobroma Cacoa) in an open-core gasifier

Quantification and characterization of cocoa pod husks for electricity generation in Uganda

An Experimental And Response-Surface-Based Optimization Approach Towards Production Of Producer Gas In A Circulating Fluidized Bed Gasifier Using Blends Of Renewable Fibre-Based Biomass Mixtures

Co-gasification of different biomass feedstock in a pilot-scale (24 kWe) downdraft gasifier: An experimental approach

Pyrolysis of cocoa shell and its bioenergy potential: evaluating the kinetic triplet, thermodynamic parameters, and evolved gas analysis using TGA-FTIR

Evaluation of Gas Composition Obtained from Gasification of Pellets and Blends with Agricultural Wastes

Gasification property of agriculture wastes in an updraft fixed bed gasifier with top-lit ignition

Numerical investigation of sugarcane bagasse gasification using Aspen Plus and response surface methodology

Biomass Pyrolytic Polygeneration System: Adaptability for Different Feedstocks

Techno-economic assessment of sugarcane bagasse pith-based briquette production and performance analysis of briquette feed gasifier-engine system

Comparative Investigation on the Pyrolysis of Crop, Woody, and Herbaceous Biomass: Pyrolytic Products, Structural Characteristics, and CO2 Gasification

Emerging potential of spent coffee ground valorization for fuel pellet production in a biorefinery

Pyrolysis characteristics and kinetic investigation of waste groundnut shells using thermogravimetric analyzer, Py-FTIR, and Py-GC-MS

Combustion of pellets produced from corn straw and cashew nut shell in residential and industrial scenarios: Chemical, thermal and emission analyses

Valorization of coconut and banana wastes with petcoke and coal via steam gasification in a fluidized bed reactor

Pyrolysis of Sugarcane ( L.) Leaves and Characterization of Products.

Plasma gasification performances of various raw and torrefied biomass materials using different gasifying agents

Investigation on Blending Ratios of Small Particle Size Spent Tea Waste with Bulk Density Agricultural Residues to Enhance the Performance of Downdraft Gasifier

Catalytic co-gasification optimization of biomass and polyethylene wastes in oxygen-rich environments

Gasification of Binderless Co‐pelletized Hydrochars from Banana Leaves and Coconut Sawdust

Pyrolysis Behavior and Economics Analysis of the Biomass Pyrolytic Polygeneration of Forest Farming Waste