Abstract:Background: Microalgae have attracted considerable interest due to their ability to produce a wide range of valuable compounds. Pulsed Electric Fields (PEF) has been demonstrated to effectively disrupt the microalgae cells and facilitate intracellular extraction. To increase the commercial viability of microalgae, the entire biomass should be exploited with different products extracted and valorized according to the biorefinery scheme. However, demonstrations of multiple component extraction in series are very limited in literature. This study aimed to develop an effective lipid extraction protocol from wet Scenedesmus almeriensis after PEF-treatment with 1.5 MJ·kgDW-1. A cascade process, i.e., the valorization of several products in row, was tested with firstly the collection of the released carbohydrates in the water fraction, then protein enzymatic hydrolysis and finally lipid extraction. Biomass processed with high pressure homogenization (HPH) on parallel, served as benchmark. Results: Lipid extraction with ethanol:hexane (1:0.41 vol/vol) offered the highest yields from the different protocols tested. PEF-treatment promoted extraction with almost 70% of total lipids extracted against 43% from untreated biomass. An incubation step after PEF-treatment, further improved the yields, up to 83% of total lipids. Increasing the solvent volume by factor 2 offered no improvement. In comparison, extraction with two other systems utilizing only ethanol at room temperature or elevated at 60 °C were ineffective with less than 30% of total lipids extracted. Regarding cascade extraction, carbohydrate release after PEF was detected albeit in low concentrations. PEF-treated samples displayed slightly better kinetics during the enzymatic protein hydrolysis compared to untreated or HPH-treated biomass. The yields from a subsequent lipid extraction were not affected after PEF but were significantly increased for untreated samples (66% of total lipids), while HPH displayed the lowest yields (~ 49% of total lipids). Conclusions: PEF-treatment successfully promoted lipid extraction from S. almeriensis but only in combination with a polar:neutral co-solvent (ethanol:hexane). After enzymatic protein hydrolysis in cascade processing; however, untreated biomass displayed equal lipid yields due to the disruptive effect of the proteolytic enzymes. Therefore, the positive impact of PEF in this scheme is limited on the improved reaction kinetics exhibited during the enzymatic hydrolysis step.

The Effect of the Aqueous Enzymatic Extraction Method towards Momordica charantia Seed Oil and Its Lignocellulosic Biomass

Aqueous Enzymatic Extraction and Demulsification of Camellia Seed Oil (camellia Oleifera Abel.) and the Oil's Physicochemical Properties

Analysis of the lipid extraction performance in a cascade process for Scenedesmus almeriensis biorefinery

Semi-Continuous Microwave-Assisted Oil Extraction and Enzymatic Hydrolysis of Butia Odorata Seeds: Efficient Recovery of Oil and Fermentable Sugars in a Sequential Method

In situ lipase-catalyzed reactive extraction of oilseeds with short-chained dialkyl carbonates for biodiesel production.

A novel process for the aqueous extraction of oil from Camellia oleifera seed and its antioxidant activity

Chemical Characterization and Biological Activities Evaluation of Myrtus communis L. Essential Oil Extraction By-Product towards Circular Economy and Sustainability

Aqueous Extraction of Seed Oil from Mamey Sapote (Pouteria sapota) after Viscozyme L Treatment

Profiling the effects of microwave-assisted and soxhlet extraction techniques on the physicochemical attributes of Moringa oleifera seed oil and proteins

Protein Recovery and DPPH Radical Scavenging Activity of Enzymolyzed Products of Moringa Oleifera Seed

Sustainable and Biomimetic Methodology for Extraction of High-Value-Added Compounds in Almond Hulls

Lipase-catalyzed in situ reactive extraction of oilseeds with short-chained alkyl acetates for fatty acid esters production

Evaluation of the Extraction of Bioactive Compounds and the Saccharification of Cellulose as a Route for the Valorization of Spent Mushroom Substrate

Optimization of an Aqueous Enzymatic Method and Supercritical Carbon Dioxide Extraction for Paeonia suffruticosa Andr. Seed Oil Production Using Response Surface Methodology (RSM)

Optimization of Enzyme-Assisted Extraction of Bioactive Compounds from Sea Buckthorn (Hippophae rhamnoides L.) Leaves: Evaluation of Mixed-Culture Fermentation

A novel strategy for preparing lignan-rich sesame oil from cold-pressed sesame seed cake by combining enzyme-assisted treatment and subcritical fluid extraction

Maximizing fermentable feedstocks from Camellia oleifera seed oil extraction residues: Green pretreatment and enzymatic hydrolysis for effective valorization

Phytochemical and Functional Diversity of Enzyme-Assisted Extracts from Hippophae rhamnoides L., Aralia cordata Thunb., and Cannabis sativa L

Effect of ultrasonic-assisted extraction method on the oil yield and fatty acid profile of Thraustochytrium multirudimentale and Rhodotorula mucilaginosa

Maximizing Lipid Extraction from Chlorella pyrenoidosa: A Study on the Effectiveness of Cell Disruption Techniques

Ultrasound-assisted extraction of bioactive compounds from longan seeds powder: Kinetic modelling and process optimization