Untersuchungen über Vorkommen und Wanderung von Aflatoxin B1 und seine Veränderungen bei einigen lebensmitteltechnologischen Prozessen

Ernstgeorg Hanssen,Gerhild Hagedorn

DOI: https://doi.org/10.1007/bf01883086

1969-11-01

Abstract:Using the described analytical method, the presence of aflatoxin in a range of and below 5 \gmg/kg can be determined and confirmed.Aflatoxin is produced by a mould calledAspergillus flavus on common foods if they are kept under bad storage conditions. BesidesA. flavus other kinds of Aspergillus as well asPenicillium andMucor are able to produce aflatoxin B1. Aflatoxins are carcinogens.The different strains ofA. flavus vary between practically no production of aflatoxin and high toxic ones which produce up to 100 \gmg aflatoxin B1 per gram mycelium.Even in the spores ofA. flavus aflatoxin was found. This observation is important because spores have a tendency to become airborne, especially since they are not wet by water. Mycelia and media can be readily treated to destroy aflatoxin, and would not constitute a health hazard when properly handled. Precautions must be taken to prevent spores ofA. flavus strains producing aflatoxin from getting out in the atmosphere before they are treated to destroy the toxin.Aflatoxin is excreted by the mycelium and may diffuse in a few days deeply into the foodstuffs (apple juice, coconut, dough, whole rye bread, cheese). In case of a whole rye bread we found 7 cm below the mycelium 45000 μg aflatoxin B1 per kg. Our results show a possible danger for consumers who eat foodstuffs with closely cut-off mould.The heat resistance of aflatoxin is the reason for its stability against the normal heat treatments in the food industry.Regarding detoxification of food stuff containing aflatoxin some general considerations are first outlined and the special problems of each type of product indicated. Results are given on literature and own experimental work as exposure to ultraviolet radiation and heat. These and other treatments (solvent extraction, reactive gases, reduction by microorganisms) were practically unsuccessful. It is included that detoxification has little potentiality and that the emphasis must be on the prevention of aflatoxin contamination.The Food and Agriculture Organization and the World Health Organization established a level of 30 \gmg/kg aflatoxin for foodstuffs. Aflatoxin is 1000\2-1500 times more virulent than butter yellow, a butter additive which is prohibited all over the world.In Great Britain, Canada, and the Netherlands the highest level is 5 μg/kg aflatoxin in food-stuffs. In the USA, Switzerland and the German Federal Republic no tolerance can be set for these substances as demonstrable concentration of aflatoxins is proof of excessive contamination with toxins of fungal origin.