Abstract:BackgroundSaccharomyces cerevisiae, engineered for l-lactic acid production from glucose and xylose, is a promising production host for lignocellulose-to-lactic acid processes. However, the two principal engineering strategies—pyruvate-to-lactic acid conversion with and without disruption of the competing pyruvate-to-ethanol pathway—have not yet resulted in strains that combine high lactic acid yields (YLA) and productivities (QLA) on both sugar substrates. Limitations seemingly arise from a dependency on the carbon source and the aeration conditions, but the underlying effects are poorly understood. We have recently presented two xylose-to-lactic acid converting strains, IBB14LA1 and IBB14LA1_5, which have the l-lactic acid dehydrogenase from Plasmodium falciparum (pfLDH) integrated at the pdc1 (pyruvate decarboxylase) locus. IBB14LA1_5 additionally has its pdc5 gene knocked out. In this study, the influence of carbon source and oxygen on YLA and QLA in IBB14LA1 and IBB14LA1_5 was investigated.ResultsIn anaerobic fermentation IBB14LA1 showed a higher YLA on xylose (0.27 g gXyl−1) than on glucose (0.18 g gGlc−1). The ethanol yields (YEtOH, 0.15 g gXyl−1 and 0.32 g gGlc−1) followed an opposite trend. In IBB14LA1_5, the effect of the carbon source on YLA was less pronounced (~ 0.80 g gXyl−1, and 0.67 g gGlc−1). Supply of oxygen accelerated glucose conversions significantly in IBB14LA1 (QLA from 0.38 to 0.81 g L−1 h−1) and IBB14LA1_5 (QLA from 0.05 to 1.77 g L−1 h−1) at constant YLA (IBB14LA1 ~ 0.18 g gGlc−1; IBB14LA1_5 ~ 0.68 g gGlc−1). In aerobic xylose conversions, however, lactic acid production ceased completely in IBB14LA1 and decreased drastically in IBB14LA1_5 (YLA aerobic ≤ 0.25 g gXyl−1 and anaerobic ~ 0.80 g gXyl−1) at similar QLA (~ 0.04 g L−1 h−1). Switching from aerobic to microaerophilic conditions (pO2 ~ 2%) prevented lactic acid metabolization, observed for fully aerobic conditions, and increased QLA and YLA up to 0.11 g L−1 h−1 and 0.38 g gXyl−1, respectively. The pfLDH and PDC activities in IBB14LA1 were measured and shown to change drastically dependent on carbon source and oxygen.ConclusionEvidence from conversion time courses together with results of activity measurements for pfLDH and PDC show that in IBB14LA1 the distribution of fluxes at the pyruvate branching point is carbon source and oxygen dependent. Comparison of the performance of strain IBB14LA1 and IBB14LA1_5 in conversions under different aeration conditions (aerobic, anaerobic, and microaerophilic) further suggest that xylose, unlike glucose, does not repress the respiratory response in both strains. This study proposes new genetic engineering targets for rendering genetically engineering S. cerevisiae better suited for lactic acid biorefineries.

How water‐soluble saccharides drive the metabolism of lactic acid bacteria during fermentation of brewers' spent grain

Microbial Fermentation of the Water-Soluble Fraction of Brewers’ Spent Grain for the Production of High-Value Fatty Acids

The microbiota and metabolome dynamics and their interactions modulate solid-state fermentation process and enhance clean recycling of brewers' spent grain

Brewers’ spent grain as substrate for dextran biosynthesis by Leuconostoc pseudomesenteroides DSM20193 and Weissella confusa A16

Fermented Brewers’ Spent Grain Containing Dextran and Oligosaccharides as Ingredient for Composite Wheat Bread and Its Impact on Gut Metabolome In Vitro

Brewer's spent grain as a self-sufficient feedstock for homofermentative production of optically pure L-lactic acid using Lactobacillus rhamnosus

Uncovering carbohydrate metabolism through a genotype-phenotype association study of 56 lactic acid bacteria genomes

Anaerobic biotransformation process of lignocellulosic waste with Lactobacillus casei and Bacillus subtilis and its effect on the physicochemical parameters case of study: craft brewers’ spent grains

Why do lactic acid bacteria thrive in chain elongation microbiomes?

Population dynamics and metabolite target analysis of lactic acid bacteria during laboratory fermentations of wheat and spelt sourdoughs

Understanding microbiome dynamics and functional responses during acidogenic fermentation of sucrose and sugarcane vinasse through metatranscriptomic analysis

Integrated Metabolomics and Metagenomics Unveiled Biomarkers of Antioxidant Potential in Fermented Brewer's Grains

Kinetic Model for Simultaneous Saccharification and Fermentation of Brewers’ Spent Grain Liquor Using Lactobacillus delbrueckii Subsp. lactis

Metabolic responses of Lactobacillus plantarum strains during fermentation and storage of vegetable and fruit juices

Saccharomyces cerevisiae strains performing similarly during fermentation of lignocellulosic hydrolysates show pronounced differences in transcriptional stress responses

Temporal Expression Dynamics of Plant Biomass-Degrading Enzymes by a Synthetic Bacterial Consortium Growing on Sugarcane Bagasse

Transcription analysis of recombinant industrial and laboratory Saccharomyces cerevisiae strains reveals the molecular basis for fermentation of glucose and xylose

The prebiotic potential of brewers' spent grain on livestock's health: a review

Successive process for efficient biovalorization of Brewers' spent grain to lignocellulolytic enzymes and lactic acid production through simultaneous saccharification and fermentation

l-Lactic acid production from glucose and xylose with engineered strains of Saccharomyces cerevisiae: aeration and carbon source influence yields and productivities

Brewers’ spent grain liquor as a feedstock for lactate production with Lactobacillus delbrueckii subsp. lactis