Abstract:Three upflow anaerobic sludge blanket (UASB) pilot scale reactors with different configurations and inocula: flocculent biomass (F-UASB), flocculent biomass and membrane solids separation (F-AnMBR) and granular biomass and membrane solids separation (G-AnMBR) were operated to compare start-up, solids hydrolysis and effluent quality. The parallel operation of UASBs with these different configurations at low temperatures (9.7 ± 2.4°C) and the low COD content (sCOD 54.1 ± 10.3 mg/L and pCOD 84.1 ± 48.5 mg/L), was novel and not previously reported. A quick start-up was observed for the three reactors and could be attributed to the previous acclimation of the seed sludge to the settled wastewater and to low temperatures. The results obtained for the first 45 days of operation showed that solids management was critical to reach a high effluent quality. Overall, the F-AnMBR showed higher rates of hydrolysis per solid removed (38%) among the three different UASB configurations tested. Flocculent biomass promoted slightly higher hydrolysis than granular biomass. The effluent quality obtained in the F-AnMBR was 38.0 ± 5.9 mg pCOD/L, 0.4 ± 0.9 mg sCOD/L, 9.9 ± 1.3 mg BOD5/L and <1 mg TSS/L. The microbial diversity of the biomass was also assessed. Bacteroidales and Clostridiales were the major bacterial fermenter orders detected and a relative high abundance of syntrophic bacteria was also detected. Additionally, an elevated abundance of sulfate reducing bacteria (SRB) was also identified and was attributed to the low COD/SO42– ratio of the wastewater (0.5). Also, the coexistence of acetoclastic and hydrogenotrophic methanogenesis was suggested. Overall this study demonstrates the suitability of UASB reactors coupled with membrane can achieve a high effluent quality when treating municipal wastewater under psychrophilic temperatures with F-AnMBR promoting slightly higher hydrolysis rates.

Tracer Studies in a Laboratory and Pilot Scale UASB Reactor

Performance of the UASB reactor during wastewater treatment and the effect of the biogas bubbles on its hydrodynamics

A Case for Aerobic Sludge Granulation: from Pilot to Full Scale

Review of Upflow Anaerobic Sludge Blanket Reactor Technology: Effect of Different Parameters and Developments for Domestic Wastewater Treatment

Hydrolysis and Methanogenesis in UASB-AnMBR Treating Municipal Wastewater Under Psychrophilic Conditions: Importance of Reactor Configuration and Inoculum

The Structure, Density and Settlability of Anammox Granular Sludge in High-Rate Reactors.

Hydrodynamics of Upflow Anaerobic Sludge Blanket Reactors

Dynamic Behavior and Concentration Distribution of Granular Sludge in a Super-High-rate Spiral Anaerobic Bioreactor

Novel Insight of Spatial Mass Transfer Conditions of Upflow Anaerobic Reactor

Impact of Influent Composition and Operating Conditions on Carbon and Nitrogen Removal from Urban Wastewater in a Continuous-Upflow (Micro)Aerobic Granular Sludge Blanket Reactor

Combined System UASB+MBR for the Biological Elimination of Emerging Contaminants, Organic Matter and Nutrients in Urban Waste Water

Multiscale Hydrodynamic Investigation to Intensify the Biogas Production in Upflow Anaerobic Reactors

Pilot-scale in-situ biomethanation of sewage sludge: Effects of gas recirculation method

Attached and suspended biomass kinetics in an IFAS-MBR system operated under intermittent aeration: Long-term monitoring under SRT variation

The effect of slime accumulated in a long-term operating UASB using crude glycerol to treat S-rich wastewater

A New Degassing Membrane Coupled Upflow Anaerobic Sludge Blanket (UASB) Reactor to Achieve In-Situ Biogas Upgrading and Recovery of Dissolved CH4 from the Anaerobic Effluent

Influence of filling ratio and carrier type on organic matter removal in a moving bed biofilm reactor with pretreatment of electrocoagulation in wastewater treatment

Performance of Anaerobic Granular Sludge Bed Reactor with Biogas Recirculation

Recovery of methane dissolved in the effluent of a novel upflow anaerobic hybrid reactor (UAHB) submitted to temperature variation

Non-uniform dissolved oxygen distribution and high sludge concentration enhance simultaneous nitrification and denitrification in a novel air-lifting reactor for municipal wastewater treatment: A pilot-scale study

Filamentous Granular Sludge Bulking in a Laboratory Scale UASB Reactor.