Abstract:One of the main factors for the effective functioning of the power supply system in highly productive coal mines is the uninterrupted power supply of underground consumers for the entire process cycle at sufficient amount of electric energy at a high level of quality and performance. The analysis of electric energy consumption in highly productive coal mine has shown that about 57 % of electric energy consumers are located in underground workings. Consumers can be divided into the following areas of basic technological process of coal production: production areas (13 %); conveyor transport areas (13 %); preparation areas (8 %), and areas of auxiliary processes of coal production: mine drainage (23 %). The increase in the share of controlled-velocity electric drives in the total power balance of fully-mechanized longwalls leads to factors previously atypical of underground power networks. Such factors include changes to the harmonic composition of the network, arising higher current and voltage harmonics, affecting the supplying network and causing heating of electrical equipment, power and electric energy losses. Therefore, the most pressing issues are to improve electric energy quality in underground electric networks of highly productive coal mines. The study has developed a technique for experimental investigations of quality indicators of electric energy (presented in the form of algorithm) in respect to specific conditions of highly productive coal mines. These include dangerous facilities in terms of sudden gas/dust outbursts. This technique was tested at a number of coal mines of JSC SUEK-Kuzbass. The study also presents the results of experimental investigations to determine the actual level of total harmonic distortion (factor) in underground electric networks of fully-mechanized longwalls of coal mines. Of greater importance is justification of higher harmonic filter parameters. To this end a calculation algorithm based on the developed technique has been proposed. Research has shown that application of forward and inverse Clarke transformations for calculating the harmonic filter parameters is applicable for all voltage levels. The simulation model of power supply system of a coal mine fully-mechanized longwall allows conditions of higher harmonics damping to be studied by means of a device for improvement of electric energy quality. Applying the proposed technical solutions to improve the quality of electric energy based on the simulation modeling allowed the successful damping of higher harmonics to be achieved. For example, the total harmonic components voltage (THD (U)) was reduced from 9.07 to 1.77 %.

Prediction of the Performance of On-line Ash Analyzers Used in the Quality Control Process of a Coal Mining System

Enhanced Just-In-Time Modelling for Online Quality Prediction in Bf Ironmaking

The Online Correction of Gamma-ray Ash Monitor in Coal Preparation Plant

Real-time in situ monitoring of ash content in coal via dual-energy X-rays and an MLP neural network

A Novel Coal Mine Dust Measurement System and Experimental Analysis

Real-Time Prediction of Oil-Type Gas Emissions in Coal-Oil-Gas Coexistence Mines

Improvement of the electric energy quality in underground electric networks in highly productive coal mines

Methodological bases for assessing the health of equipment being part of robotic coal mining complexes and predicting its changes during operation

Mechanism of measuring ash with low-energy gamma rays for equal coal seam thickness

Multi-information online detection of coal quality based on machine vision

A Support Vector Machine Based Prediction on Sensitivity to Coal Ash Blast for Different Degrees of Deterioration

The use of the neuro-fuzzy model to predict the methane hazard during the underground coal mining production process

Comparison and Determination of Optimal Machine Learning Model for Predicting Generation of Coal Fly Ash

Research on Dual GRU model driving by time series alignment for multi-step prediction of ash content of dense medium clean coal

Prediction of operation vibration state of coal mine mechatronics equipment based on data mining

Performance prediction of a clean coal power plant via machine learning and deep learning techniques

Prediction of Gas Emissions in the Working Face Based on the Desorption Effects of Granular Coal: A Case Study

On the Performance Assessment of ANN and Spotted Hyena Optimized ANN to Predict the Spontaneous Combustion Liability of Coal

Study on gas emission prediction of working face based on GM (1, 1) model

A Method for Assessing the Impact of Changes in Demand for Coal on the Structure of Coal Grades Produced by Mines

Safety Analysis and Management Measures of In-service Large Capacity Lithium Battery for Underground Mining