Abstract:The mushroom agroindustry generates a huge amount of waste from mushroom production (WMP). The composition of WMP is not standardized but differs mainly in terms of organic matter (OM) content and OM biodegradability. This makes WMP management, including anaerobic digestion (AD), a significant challenge. A potential solution could be co-digestion of WMP with municipal sewage sludge (SS), especially SS generated in small rural wastewater treatment plants (WWTPs). Therefore, this study investigated mesophilic methane production (MP) from WMP, SS, and mixtures of SS and WMP at ratios of 70:30, 50:50, and 30:70 (w/w OM). Even though the maximum cumulative MP from WMP was relatively low (approx. 60 NL/kg OM), co-digesting WMP with SS increased both MP and the methane content of the biogas: with 30%, 50%, and 70% shares of SS, MP increased almost 2, 2.5, and 3.3 times, and the methane content increased to 61%, 62%, and 64%, respectively. As the SS content was increased, the kinetic coefficients of MP and OM removal decreased (from 0.211 to 0.146 d−1 and from 0.215 to 0.152 d−1), whereas the initial rate of MP and of OM removal increased (from 12.5 to 36.8 NL/(kg OM·d) and from 0.51 kg OM/(m3·d) to 0.59 kg OM/(m3·d), respectively). The effectiveness of OM removal (EOMrem) was lowest with WMP only, at 46.6%. When the SS content of the mixtures was increased to 30%, 50%, and 70%, EOMrem also increased to 55.3%, 60.1%, and 64.9%, respectively. The relationship between maximal MP and the overall OM removed was such that both increased simultaneously. The higher values of EOMrem and, consequently, the lower final contents of OM with more effective MP indicate that the organics were degraded more efficiently. These results suggest that co-digestion may be a profitable solution for simultaneously utilizing both of these waste products, increasing the efficiency of biogas production to such an extent that it would be profitable to conduct AD on mushroom farms. This is a flexible approach that allows varying proportions of WMP and SS to be used, depending on the availability of both substrates and the energy needs of the mushroom farm. However, it should be borne in mind that a higher share of WMP results in lower gas productivity.

Enhancing methane production by anaerobic co-digestion of extruded organic wastes from slaughterhouse and vegetable market in batch and continuous processes

Enhancement of Methane Production from Vegetable, Fruit and Flower Market Wastes Using Extrusion as Pretreatment and Kinetic Modeling

Influence of pre-treatments and anaerobic co-digestion of slaughterhouse waste with vegetable, fruit and flower market wastes for enhanced methane production

Experimental investigation of biogas production by co-digestion of local vegetable market wastes

Evaluation of anaerobic co-digestion of dairy manure with food wastes via bio-methane potential assay and CSTR reactor.

Anaerobic Digestion as a Possible Method of Managing Waste from Mushroom Production with Sewage Sludge as Co-Substrate

Anaerobic Co-digestion of Expired Dairy Products and Synthetic Domestic Wastewater: Effect on Methane Potential in Batch Reactors

Use of Continuous Stirred Tank Reactors for Anaerobic Co-Digestion of Dairy and Meat Industry By-Products for Biogas Production

Stimulating Methane Production from Poultry Manure Digest with Sewage Sludge and Organic Waste by Thermal Pretreatment and Adding Iron or Sodium Hydroxide

Microbial Analysis and Methane Assessment of Trinary Anaerobic Co-Digestion of Organic Fraction of Municipal Solid Waste

Enhancing biomethanation performance through co-digestion of diverse organic wastes: a comprehensive study on substrate optimization, inoculum selection, and microbial community analysis

Biomethane Production from the Two-Stage Anaerobic Co-Digestion of Cow Manure: Residual Edible Oil with Two Qualities of Waste-Activated Sludge

Effect of mixture ratio on co-digestion of vegetable and fruit waste with macro-algae, chicken manure and tofu dregs

Assessment of the Biochemical Methane Potential of Wastewater and Sludge Cake from a Poultry Slaughterhouse

Methane production from anaerobic mono- and co-digestion of kitchen waste and sewage sludge: synergy study on cumulative methane production and biodegradability

Evaluation of biogas production and pollutant removal efficiency of two-phase anaerobic digestion treating slaughterhouse effluent

Anaerobic co-digestion of activated sludge and fruit and vegetable waste: Evaluation of mixing ratio and impact of hybrid (microwave and hydrogen peroxide) sludge pre- treatment on two-stage digester stability and biogas yield

Biogas potential of organosolv pretreated wheat straw as mono and co-substrate: substrate synergy and microbial dynamics

Biogas production by co‐digestion of municipal wastewater and food waste: Performance in semi‐continuous and continuous operation

Efficient methane production from anaerobic co-digestion of lignin-based feedstock and waste plastic: Digester performance and microbial community structures

Advances on characteristics and valorization of food waste towards the sustainable production of bio-methane and purification