Abstract:The effect of fortifying reconstituted skim milk with increasing levels of the beta-lactoglobulin (beta-LG) genetic variants A, B, and an A-B mixture on rennet-induced gelation was studied by small deformation-sensitive rheology. Free-zone capillary electrophoresis and high-sensitivity oscillatory rheology were used to elucidate the role of potential heterotypic associative interactions between whey proteins and casein in a mixed colloidal system, subjected to moderate heating (65 degrees C for 30 min) prior to renneting, on the gelling properties of the system. Increasing levels of added whey protein, in the concentration range of 0.225 to 1.35% of added protein, led to a concomitant progressive increase in the equilibrium shear storage modulus, G' (recorded after approximately 10,800 s), in the order beta-LG B > beta-LG A and beta-LG A-B, as the general expected consequence of the setup of denser casein gel networks. The preferential effect of beta-LG B over beta-LG A on the mechanical strength of the gels may be due to the formation of cross-links and aggregates involving whey proteins and rennet hydrolysis products or an increase in the size of the casein micelle caused by the grafting of beta-LG B to its surface, or both. The results of free-zone capillary electrophoresis were consistent with the notion that beta-LG B (and not beta-LG A) binds to the casein micelle under an optimal stoichiometry of 1:0.045 (mg/mg), even in the absence of heat treatment. The liquid-like character of the gel networks formed, tan delta, was a parameter sensitive to the level of addition of beta-LG A in particular. At low concentrations (up to 0.45%) of beta-LG A, tan delta increased by almost twice as much, which was interpreted as a result of the increase in the loss modulus, G'', of the sol fraction because of the presence of unbound beta-LG A. At greater incremental concentrations of beta-LG (>0.45%), the formation of smaller whey protein aggregates confined to the sol fraction may have led to a progressive decrease in tan delta. The critical gel time, t(gel), was also affected by the concentration of added whey protein and described 3 zones of behavior, irrespective of the type of whey protein variant. The critical gel time was slightly shorter for beta-LG B than for beta-LG A at 0.45% of added whey protein, but this difference became larger at 0.67%. Even when only beta-LG B was found to associate with casein prior to renneting, both beta-LG A and beta-LG B, either alone or mixed, had a profound influence on the mechanical strength and coagulation kinetics of the rennet-induced casein gels. This knowledge is expected to be useful to exert better control and optimize processing conditions during the manufacturing of cheese and cheese analogs.

Distribution of Clot-Inhibiting Free Fatty Acids in Ultracentrifugal Fractions of Reconstituted Skim Milk Powder

Inhibitory Effects of Fatty Acids, Chelating Agents, and other Substances on Rennet Clotting of Skim Milk

Influence of pH on Heat-Induced Changes in Skim Milk Containing Various Levels of Micellar Calcium Phosphate

Effect of dipotassium phosphate addition and heat on proteins and minerals in milk protein beverages.

Milk beverage base with lactose removed with ultrafiltration: Effect of fat and protein concentration on sensory and physical properties

Differences in Several Important Proteins Contents Between Raw Milk and Reconstituted Milk

QUALITY OF PROTEIN IN MILK REPLACERS FOR YOUNG CALVES. IV. RENNET (CHYMOSIN, RENNIN) COAGULATION OF RECONSTITUTED SKIM MILK POWDER CONTAINING ADDED PROTEINS, FAT, CALCIUM, PHOSPHATE AND CITRATE

Characterization of high pressure jet-induced fat-protein complexation

Effects of mineral salts and calcium chelating agents on the gelation of renneted skim milk

In vivo digestion of bovine milk fat globules: effect of processing and interfacial structural changes. I. Gastric digestion

Structural and physical-chemical properties of milk fat globules fractionated by a series of silicon carbide membranes

The nature of the substances adsorbed on the surface of the fat globules in cow's milk. (Preliminary Report).

[7] Purification and assay of rennin

Influence of Chymosin on Physicochemical and Hydrolysis Characteristics of Casein Micelles and Individual Caseins

Enrichment of Lactoferrin and Immunoglobulin G from Acid Whey by Cross-Flow Filtration

New insights into the destabilization of fat globules in ultra-instantaneous UHT milk induced by added plasmin: molecular mechanisms and the effect of membrane structure on plasmin action

Structural Properties of Casein Micelles with Adjusted Micellar Calcium Phosphate Content

Extent of κ‐casein hydrolysis during renneting of bovine milk: A critical assessment of the analytical and estimation approaches

Effect of β-Lactoglobulin A and B Whey Protein Variants on the Rennet-Induced Gelation of Skim Milk Gels in a Model Reconstituted Skim Milk System

Proteomic Comparisons of Caprine Milk Whole Cream Buttermilk Whey and Cheese Whey Cream Buttermilk

Isolation and identification of milk-clotting proteases from Prinsepia utilis Royle and its application in cheese processing