Abstract:Innovative clean label processes employed in the manufacture of acid gels are targeted to modify the structure of proteins that contribute to rheological properties. In the present study, CO2-treated milk protein concentrate powder with 80% protein in dry matter (TMPC80) was mixed with nonfat dry milk (NDM) in different ratios for the manufacture of acid gels. Dispersions of NDM and TMPC80 that provided 100, 90, 70, and 40% of protein from NDM were reconstituted to 4.0% (wt/wt) protein and 12.0% (wt/wt) total solids. Dispersions were adjusted to pH 6.5, followed by heat treatment at 90°C for 10 min. Glucono-δ-lactone was added and samples were incubated at 30°C, reaching pH 4.5 ± 0.05 after 4 h of incubation. Glucono-δ-lactone levels were adjusted to compensate for the lower buffering capacity of samples with higher proportions of TMPC80, which is attributable to the depletion of buffering minerals from both the serum and micellar phase during preparation of TMPC80. Sodium dodecyl sulfate-PAGE analysis indicated a higher amount of caseins in the supernatant of unheated suspensions with increasing proportions of CO2-treated TMPC80, attributable to the partial disruption of casein micelles in TMPC80. Heat treatment reduced the level of whey proteins in the supernatant due to the heat-induced association of whey proteins with casein micelles, the extent of which was larger in samples containing more micellar casein (i.e., samples with a lower proportion of TMPC80). Particle size analysis showed only small differences between nonheated and heated dispersions. Gelation pH increased from ˜5.1 to ˜5.3, and the storage modulus of the gels at pH 4.5 increased from ˜300 to ˜420 Pa when the proportion of protein contributed by TMPC80 increased from 0 to 60%. Water-holding capacity also increased and gel porosity decreased with increasing proportion of protein contributed by TMPC80. The observed gel properties were in line with microstructural observations by confocal microscopy, wherein sample gels containing increasing levels of TMPC80 exhibited smaller, well-connected aggregates with uniform, homogeneous pore sizes. We concluded that TMPC80 can be used to partially replace NDM as a protein source to improve rheological and water-holding properties in acid gels. The resultant gels also exhibited decreased buffering, which can improve the productive capacity of yogurt manufacturing plants. Overall, the process can be leveraged to reduce the amount of hydrocolloids added to improve yogurt consistency and water-holding capacity, thus providing a path to meet consumer expectations of clean label products.

Instability of Pressure-Treated Reconstituted Skim Milk to Acidification

Influence of pH on Heat-Induced Changes in Skim Milk Containing Various Levels of Micellar Calcium Phosphate

Effect of dipotassium phosphate addition and heat on proteins and minerals in milk protein beverages.

Study on potential antigenicity and functional properties of whey protein treated by high hydrostatic pressure based on structural analysis

Calcium induced skim-milk gelation during heating as affected by pH

Effects of milk pH alteration on casein micelle size and gelation properties of milk

Effect of the pH of heating on the qualitative and quantitative compositions of the sera of reconstituted skim milks and on the mechanisms of formation of soluble aggregates

High-pressure processing of bovine milk: Effects on the coagulation of protein and fat globules during dynamic in vitro gastric digestion

Rheological and structural properties of acid-induced milk gels as a function of β-casein phenotype

Heat-induced changes in milk fat and milk fat globules and its derived effects on acid dairy gelation – A review

Formation and Physical Properties of Milk Protein Gels

Influence of partially demineralized milk proteins on rheological properties and microstructure of acid gels

Kinetics of heat-induced whey protein denaturation and aggregation in skim milks with adjusted whey protein concentration

Rheological and structural properties of differently acidified and renneted milk gels

Application of pressure homogenization on whole human milk pasteurized by high hydrostatic pressure: Effect on protein aggregates in milk fat globule membrane and skim milk phases

Intragastric restructuring dictates the digestive kinetics of heat-set milk protein gels of contrasting textures

Characterization of high pressure jet-induced fat-protein complexation

Improvement of rheological properties of firm acid gels by skim milk heating is conserved after stirring

Effects of the thermal denaturation degree of a whey protein isolate on the strength of acid milk gels and the dissociation of κ-casein

Effect of homogenization and pasteurization on the structure and stability of whey protein in milk.

Effect of heating strategies on whey protein denaturation--Revisited by liquid chromatography quadrupole time-of-flight mass spectrometry.