Abstract:Introduction: Bacterial contamination of blood products presumably occurs mainly during blood collection, starting from low initial concentrations of 10–100 colony-forming units (CFUs) per bag. As little is known about bacterial growth behavior and distribution in stored whole blood (WB) and WB-derived blood products, this study aims to provide data on this subject. Methods: WB units were inoculated with transfusion-relevant bacterial species ( Acinetobacter baumannii, Bacillus cereus, Escherichia coli, Klebsiella pneumoniae, Listeria monocytogenes, Pseudomonas fluorescens, Serratia marcescens, Staphylococcus aureus, Staphylococcus epidermidis, Streptococcus dysgalactiae, Streptococcus pyogenes, Yersinia enterocolitica ; n = 12 for each species), stored for 22–24 h at room temperature, and then centrifuged for separation into plasma, red blood cells (RBCs), and buffy coats (BCs). The latter were pooled with 3 random donor BCs and one unit of PAS-E each to yield plasma-reduced platelet concentrates (PCs). Samples for bacterial colony counting were collected after WB storage and immediately after blood component production. Sterility testing in PCs ( n = 12 for each species) was performed by bacterial culture after 7 days of storage. Results: Bacterial growth in WB varied remarkably between donations and species. Streptococcus species produced the highest titers in WB, whereas Staphylococcus aureus , Staphylococcus epidermidis , Escherichia coli, and Pseudomonas fluorescens did not multiply. Centrifugation resulted in preferential accumulation of bacteria in BCs, with titers of up to 3.5 × 10 3 CFU/mL in BCs and up to ≤0.9 × 10 3 CFU/mL in BC-derived PCs. Overall, 72/144 PCs (50%) tested positive for bacteria after storage. Sterility test results were species-dependent, ranging from 12 of 12 PCs tested positive for Streptococcus pyogenes to 1 of 12 PCs positive for Escherichia coli . Bacterial contamination of RBC and plasma units was much less common and was associated with higher initial bacterial counts in the parent WB units. Conclusions: Bacterial growth in WB is species-dependent and varies greatly between donations. Preferential accumulation of bacteria in BCs during manufacturing is a critical determinant of the contamination risk of BC-derived pooled PCs.

Effect of Safety Measures on Bacterial Contamination Rates of Blood Components in Germany

Incidence of bacterial transmission and transfusion reactions by blood components

Growth and Distribution of Bacteria in Contaminated Whole Blood and Derived Blood Components

Routine bacterial screening of platelet concentrates by flow cytometry and its impact on product safety and supply

Evaluation of Risk Minimisation Measures for Blood Components - Based on Reporting Rates of Transfusion-Transmitted Reactions (1997-2013)

Quality Assessment of Established and Emerging Blood Components for Transfusion

Operational feasibility of routine bacterial monitoring of platelets

Bacterial Contamination of Platelet Products

Bacterial contamination of platelets for transfusion: strategies for prevention

Interventions Implemented to Reduce the Risk of Transmission of Bacteria by Transfusion in the English National Blood Service

Evaluation of the value of anaerobic culture in bacterial contamination forapheresis platelets

Bacterial screening of platelet components by National Health Service Blood and Transplant, an effective risk reduction measure

A survey of blood component use in a German university hospital

Hemovigilance monitoring of platelet septic reactions with effective bacterial protection systems

Detection of Bacterial Contamination of Apheresis Platelets in a Chinese Blood Center

Bacterial Detection of Platelets: Current Problems and Possible Resolutions

The impact of red blood cell manufacturing variables on bacterial growth dynamics: a pilot study

The international experience of bacterial screen testing of platelet components with automated microbial detection systems: An update

Screening of platelets for bacterial contamination at the Welsh Blood Service

Bacterial culture of apheresis platelets: a mathematical model of the residual rate of contamination based on unconfirmed positive results

Detection of bacteria in platelet concentrates prepared from spiked single donations using cultural and molecular genetic methods