Abstract:In this paper, the characteristics analysis results of lithium-ion battery show that the essence of the inconsistency of lithium-ion battery is State-Of-Charge (SOC) inconsistency. Therefore, the disparity of SOC can be used to describe the battery inconsistency degree and investigate the equalization control strategy of lithium-ion battery. Firstly, Extended Kalman Filter (EKF) algorithm is proposed to estimate the SOC on the basis of the Ampere-Hour integral and open circuit voltage. Then, the Simscape battery model is established to estimate battery parameters, and the HPPC experiment is employed to verify the SOC estimation precision. Moreover, based on the battery SOC inconsistency laws, the battery equalization control strategy is presented. Finally, the experimental bench is set up to validate the effectiveness of the equalization strategies. Simulation results depict that with the active equalization, the dispersion of SOC drops from 9.4% to 0.84% during charging phase, while the dispersion of SOC drops from 7.4% to 4.12% and the dispersion of voltage drops from 8.54% to 0.71% during discharging phase. The experimental results show that the maximum SOC estimation error is about 4%, so this SOC estimation method meets the accuracy requirement; the 6 batteries are fully charged at the same time with charging equalization, the voltage error is within 15 mV and the voltage variance is within 2%; discharging processes of the 6 batteries are over at the same time with discharging equalization, voltage error is below 15 mV and the voltage variance is below 2%. These results indicate that active equalization control in this paper not only can improve cell inconsistency but also can improve the energy utilization of the battery pack in the process of charging and discharging.

Charging and discharging model of lithium-ion battery for charge equalization control using particle swarm optimization algorithm

Online Parameter Identification and Joint Estimation of the State of Charge and the State of Health of Lithium-Ion Batteries Considering the Degree of Polarization

Optimizing Control for System-Wide State-of-Charge Balancing in Cascaded H-Bridge Battery Energy Storage Systems

Bidirectional Active Equalization Control of Lithium Battery Pack Based on Energy Transfer

PSO-based Optimization for Constant-Current Charging Pattern for Li-Ion Battery

Particle Swarm Optimization for Energy Management Fuzzy Controller Design in Dual-Source Electric Vehicle

Active balancing strategy for AUV power battery pack based on PSO-PID algorithm

A fast active balancing strategy based on model predictive control for lithium-ion battery packs

Fuzzy Logic Control-Based Charge/Discharge Equalization Method for Lithium-Ion Batteries

A Double-Layer Ring-Structured Equalizer for Series-Connected Lithium-Ion Battery Pack Based on Model Predictive Control

Effects analysis on active equalization control of lithium-ion batteries based on intelligent estimation of the state-of-charge

Adaptive Optimal Charge Strategy for Lithium-ion Power Battery Based on Multi-Objective Algorithm

An Intelligent Active Equalization Control Strategy Based on Deep Reinforcement Learning for Lithium-ion Battery Pack

Adaptive estimation-based hierarchical model predictive control methodology for battery active equalization topologies: Part I–Balancing strategy

An improved particle swarm optimization-cubature Kalman particle filtering method for state-of-charge estimation of large-scale energy storage lithium-ion batteries

SOC Estimation-Based Quasi-Sliding Mode Control for Cell Balancing in Lithium-Ion Battery Packs

Design and Control of Bidirectional Active Balancing Model for Lithium-Ion Battery Pack

An Improved Control Strategy for the Charge Equalization of Lithium Ion Battery

Optimization of intelligent charging control strategy for collaborative response of electric vehicle based on PSO

A Novel Lithium-ion Battery Active Equalization Structure and Its Control Strategy Based on Bidirectional Converter Unit

A Modularized Equalizer for Large-Scale Battery Packs Based on Model Predictive Control