Impacts of bio-carriers on the characteristics of soluble microbial products in a hybrid membrane bioreactor for treating mariculture wastewater

Jing Zhu,Hong You,Zhipeng Li,Yi Ding,Feng Liu,Chunpeng Zhang,Shutao Wang,Yuhan Gu,Fanyu Chen,Binyu Ma

DOI: https://doi.org/10.1016/j.scitotenv.2020.140287

2020-10-01

Abstract:To gain greater insights into impacts of bio-carriers on the fate and characteristics of soluble microbial products (SMPs) for mariculture wastewater treatment, the hybrid membrane bioreactor (HMBR) and conventional membrane bioreactor (CMBR) were investigated. Both protein and polysaccharide exhibited lower level in HMBR (8.95 ± 0.28 mg/L and 20.49 ± 1.3 mg/L for anoxic stage, 5.16 ± 0.22 mg/L and 17.85 ± 0.92 mg/L for aerobic stage) than CMBR (14.6 ± 0.68 mg/L and 28.3 ± 2.99 mg/L for anoxic stage, 10.53 ± 0.68 and 26.04 ± 3.15 mg/L for aerobic stage). Three-dimensional fluorescence excitation emission matrix (EEM) revealed bio-carriers reduced the production of aromatic protein-like components in anoxic and aerobic supernatant and caused a blue-shift of soluble microbial product in aerobic stage. Molecular weight (Mw) distribution indicated that bio-carriers ameliorated the excretion of biopolymer (Mw > 500 kDa) in anoxic supernatant and intermediate Mw fractions (20-500 kDa) in aerobic supernatant. Moreover, little changes were observed in SMPs with Mw < 3 kDa down the whole treatment process of both systems. Gas chromatography-mass spectrometry (GC-MS) demonstrated that the major SMPs were long-chain alkanes and aromatics in all units of both systems and fewer aromatics were detected in HMBR. For anoxic stage, more peaks were identified in the HMBR (138) than CMBR (115), while for aerobic stage, more compounds were observed in the CMBR (94) than HMBR (70). Over 50% of the compounds in the anoxic supernatant for the HMBR were the same as in the CMBR. And 27 compounds were the same in aerobic supernatant for the HMBR and CMBR. Fewer compounds in the HMBR effluent (52) was observed, compared to CMBR effluent (80). Approximately 25.7% of compounds in the aerobic stage of the HMBR were rejected by membrane, while this value decreased to 14.9% in the CMBR.

environmental sciences