Abstract:Four wild "red" yeast strains (Rhodosporidium kratochvilovae FMCC Y70, R. toruloides NRRL Y-27013, R. toruloides NRRL Y-17902 and R. toruloides NRRL Y-6985) were cultured in shake flasks on industrial glycerol at an initial substrate (Gly0) concentration ≈ 50 g/L under nitrogen limitation. Strains NRRL Y-27013, NRRL Y-17902 and NRRL Y-6985 presented appreciable dry cell weight (DCW) and lipid synthesis (DCW up to 18–19 g/L containing lipids in quantities ≈ 47%, w/w). Strains NRRL Y-27013 and NRRL Y-6985 were further tested in higher Gly0 concentrations (≈90 g/L and ≈110 g/L) with the same initial nitrogen quantity as in the first ("screening") experiment. Both strains, despite the high Gly0 concentrations and C/N ratios (up to 120 moles/moles) imposed, presented significant DCW production (up to c. 29.0–29.5 g/L). Yeast biomass contained significant lipid (42–43%, w/w) and endopolysaccharide (up to 42%, w/w) quantities. Both lipids and endopolysaccharide quantities (in % w/w) noticeably increased as a response to the imposed nitrogen limitation. Lipids containing mainly oleic and palmitic acids constituted ideal candidates for biodiesel synthesis. Thereafter, the wastewaters derived from the lipid production process (lipid fermentation wastewaters—LFWs) were used as maceration waters in cultivations of edible and medicinal fungi, where novel (non-conventional) substrates were used in the performed cultures. CW (coffee residue + wheat straw), CB (coffee residue + beech wood shavings), OW (olive crop + wheat straw), OB (olive crop + beech wood shavings), RW (rice husk + wheat straw) and RB (rice husk + beech wood shavings) were soaked/sprayed with LFWs or tap water and utilized in the cultivation of Pleurotus, Ganoderma and Lentinula mushrooms. The impact of LFWs on the mycelial growth rate (mm/d) and biomass production was evaluated. The results show that regardless of the wetting method, the highest growth rates (6.2–6.6 mm/d) were noticed on RW and RB for Pleurotus eryngii and Ganoderma resinaceum, on OW, OB and RW for Ganoderma applanatum and on RW, OW and OB for Lentinula edodes. Nevertheless, high biomass production was obtained on substrates soaked with LFWs for Pleurotus ostreatus (RW: 443 mg/g d.w.), L. edodes (RB: 238 mg/g d.w.) and Ganoderma lucidum (RW: 450 mg/g d.w.). Overall, this study demonstrates the possibility of the industrial conversion of low-value agro-waste to mycelial mass and eventually to important food products.

Production of a β-d-glucan-rich extract from Shiitake mushrooms (Lentinula edodes) by an extraction/microfiltration/reverse osmosis (nanofiltration) process

Engineering of Ganoderma lucidum polysaccharide loaded polyvinyl alcohol nanofibers for biopharmaceutical delivery

Extraction of bioactive compounds against cardiovascular diseases from Lentinula edodes using a sequential extraction method

Purification of bioactive polysaccharides from Lentinula edodes using fixed-bed column with activated carbon

Molecular identification of Shiitake (Lentinula edodes), analysis and production of beta-glucan using beech wood sawdust waste

Alkaline Extraction, Structural Characterization, and Bioactivities of (1→6)-β-d-Glucan from Lentinus edodes

Extraction of chitin from flammulina velutipes waste: A low-concentration acid pretreatment and aspergillus Niger fermentation approach

Yeast Lipids from Crude Glycerol Media and Utilization of Lipid Fermentation Wastewater as Maceration Water in Cultures of Edible and Medicinal Mushrooms

Extraction of triterpenoid compounds from <i>Ganoderma Lucidum</i> spore powder through a dual-mode sonication process

Fabrication of chitin-glucan nanofibers: Insights into mushroom pretreatment and subsequent acidic deep eutectic solvent-based esterification

Extraction of triterpenoid compounds from Ganoderma Lucidum spore powder through a dual-mode sonication process

Optimization of the Protein Sequential Extraction for Quantitative Determination of Albumins, Globulins, Prolamins and Glutelins in Edible Mushrooms

Preparation and Identification of Peptides with α-Glucosidase Inhibitory Activity from Shiitake Mushroom (Lentinus edodes) Protein

Extraction of chitin-glucan complex from shiitake (Lentinula edodes) fruiting bodies using natural deep eutectic solvents and its prebiotic potential

Growth, fruiting and lignocellulolytic enzyme production by the edible mushroom Grifola frondosa (maitake)

Optimization of ultrasonic-assisted extraction of polysaccharides and triterpenoids from the medicinal mushroom Ganoderma lucidum and evaluation of their in vitro antioxidant capacities

Novel Organic Solvent Nanofiltration Approaches for Microbial Biosurfactants Downstream Processing

Influence of Heat Treatment and Solid-State Fermentation on the Lignocellulosic Fractions of Substrates Supporting Lentinula edodes (Berk.) Pegler Cultivation: Implications for Commercial Production

Optimization of Mycelial Biomass and Protease Production by Laccocephalum Mylittae in Submerged Fermentation

Effective production of biologically active water-soluble β-1,3-glucan by a coupled system of Agrobacterium sp. and Trichoderma harzianum

Adding-value to Ganoderma lingzhi by producing enzymes and antioxidant compounds under submerged fermentation using different culture media