Abstract:The largest rare earth (RE) reserves minerals of China is the bastnaesite (RE[CO3]F) and monazite ((RE, Th)[PO4]) mixed type RE ore in Bayan Obo, and 90% of this concentrate is processed by the sulfuric acid roasting method. However, during purification of RE sulfate leach solution with solid MgO, the RE loss is noticeable and accompanied by a mass of acid and alkali consumption and discharge of radioactive solid waste, which also causes environmental pollution. In this paper, the behavior of RE, Fe, and P during purification were investigated focusing on the effect of pH, concentration ratio of iron and phosphorus, RE concentration, and step-wise purification (based on different pH) purification. The characterization of precipitated impurities by BET specific surface area, XRD, SEM and FTIR reveal the reaction sequence of RE loss and the formation of the precipitate. Two new factors, neglected previously, were found to be the main contributors to the production of large solid-waste:(1) sulfate which exists in the form of Fe(OH)x(SO4)(3-x)/2 accounts for 9 to 12% of the total weight of the precipitate; (2) higher solid content in the purification slurry at a relatively high pH range (pH = 2.5–4.5) significantly promotes the production of precipitate and higher loss of RE during purification. This paper proposes a two-step purification method (based on different middle pH point), step (i): a low pH purification stage in which most P, Fe(III) and H+ were removed with minimum loss of RE followed by filtration; step (ii), high pH purification stage in which the rest of Fe(III) was completely removed with less than 2% RE lost caused by low solid-to-liquid ratio consuming less MgO. Through two-step purification under the most suitable conditions, the RE recovery increased by 6% while MgO consumption and solid residue production decreased by 12% and 16%, respectively. It can greatly alleviate the environmental problems with just a minimal modification of the operation conditions and equipment in the proposed process.

Extraction and purification of thorium and rare earth elements from bastnaesite mineral: a comprehensive leaching and precipitation study

Selective recovery of yttrium oxide and yttrium–europium oxide particles from fluorescent wastes by solvent extraction, precipitation, and calcination

Use of extraction chromatography for thorium purification from Eskisehir-Beylikahir Thorium-REEs ore deposit

Production of high purity rare earth mixture from iron-rich spent fluid catalytic cracking (FCC) catalyst using acid leaching and two-step solvent extraction process

Behavior of rare earth, iron, and phosphorus during purification of rare earth sulfate leach solution using magnesium oxide

Selective Liquid-Liquid Extraction of Thorium(IV) from Rare-Earth Element Mixtures

An eco-friendly and high-yield extraction of rare earth from the leaching solution of ion adsorbed minerals

Simultaneous Recovery of Cerium and Fluorine from Bastnaesite Leach Liquor by Mixtures of Cyanex 923 and Heh(Ehp)

Selective Leaching of Rare Earth Elements (REEs) from Eudialyte Concentrate after Sulfation and Thermal Decomposition of Non-REE Sulfates

Extraction of rare earth elements from monazite leach liquor using functionalized chitosan sorbents derived from shrimp waste

Efficient recovery of rare earth elements from apatite concentrate via pre-leaching, pressure leaching, and precipitation: Process evaluation

Recovering REEs from NdFeB Wastes with High Purity and Efficiency by Leaching and Selective Precipitation Process with Modified Agents

Selective Extraction of Rare Earth Elements from Monazite Ores with High Iron Content

Extraction of Titanium, Aluminum, and Rare Earth Values from Upgraded Bauxite Residue

Effect of solution chemistry on filtration performances and fouling potential of membrane processes for rare earth element recovery from red mud

Separation of Rare Earth Elements from Phosphogypsum Obtained from the Processing of Apatite Concentrate from the Chadormalu Mine by Acid Leaching

Extraction and Refining of High Purity Terbium Metal From Rare Earth Resources

An innovative technique for the separation of ion-adsorption high yttrium rare earth ore by Er (III) / Tm (III) grouping first

Recovery of rare earth elements from spent fluid catalytic cracking catalysts using leaching and solvent extraction techniques

Hydrometallurgical Processing of Bastnasite Ore: A Theoretical Approach Using Pourbaix (Eh–pH) Diagrams

Solvent Extraction of Rare Earth Ions from Nitrate Media with New Extractant Di-(2,3-dimethylbutyl)-phosphinic Acid