Abstract:An ionic liquid vesicle-based mechanochemical-assisted extraction (MCAE) method was proposed for the first time and successfully applied for the extraction of weak acid compounds from Mori Fructus. The factors affecting the extraction efficiency were evaluated systematically by means of single-factor optimization and a response surface methodology, including the volume and types of vesicle solutions, milling time, solid-to-liquid ratio, and β-cyclodextrin concentration. The highest extraction yield of weak acid compounds via MCAE was obtained under optimal conditions: a vesicle volume of 318.21 μL, a milling time of 9.87 min, and a solid-to-liquid ratio of 226.07 mg mL–1. Scanning electron microscopy and transmission electron microscopy were applied to verify the formation of vesicles and identify the physicochemical property changes during the MCAE. These changes mainly included the enhanced diffusion and dissolution of analytes resulting from the destruction of cell walls and their transfer capacities into vesicle solutions. The proposed method exhibited satisfactory linearity, with its correlation coefficients (r2) larger than 0.9993, low limits of detection of 3.98–13.89 ng mL–1, good recoveries of 84–122%, and acceptable reproducibility with relative standard deviations below 4.78%. The results indicated that the ionic liquid vesicle-based MCAE method could be a green, simple, and effective alternative for the extraction of bioactive compounds.The Supporting Information is available free of charge at https://pubs.acs.org/doi/10.1021/acssuschemeng.2c00338.Separation of C12mimBr from water after adding K2HPO4; UHPLC-MS/MS chromatograms of the four solutions in the recycle experiment; effect of the amount of ionic liquid and salt on the recovery of C12mimBr; and extraction efficiency of the C12β-CD vesicle for the selected compounds after consecutive extraction–recovery cycles (PDF)This article has not yet been cited by other publications.

Ionic Liquid−β-Cyclodextrin Vesicle-Based Mechanochemical-Assisted Extraction for the Weak Acid Compounds from Mori Fructus

Sonication-synergistic natural deep eutectic solvent as a green and efficient approach for extraction of phenolic compounds from peels of Carya cathayensis Sarg.

UPLC-Triple-TOF/MS characterization of phenolic constituents and the influence of natural deep eutectic solvents on extraction of Carya cathayensis Sarg. peels: Composition, extraction mechanism and in vitro biological activities.

Analysis of Three Effective Components in Fructus Corni and Its Preparations by Micellar Electrokinetic Capillary Chromatography.

CO2-Assisted Back-Extraction Method for Ionic Liquid Biphasic Systems

Ionic Liquids Based Simultaneous Ultrasonic and Microwave Assisted Extraction of Phenolic Compounds from Burdock Leaves

A new technique of extracting effective components from Chinese herb and natural plant--microwave assisted extraction, MAE]

Two Green Approaches for Extraction of Dihydromyricetin from Chinese Vine Tea Using Β-Cyclodextrin-based and Ionic Liquid-Based Ultrasonic-Assisted Extraction Methods

A Synergistic 'push and Pull' Ionic Liquid Biphasic System for Enhanced Extraction Separation of Cholic Acid and Deoxycholic Acid

An Extraction Process Based on the Collaborative Extraction of Coptis chinensis Franch. Phytoconstituents Using a Deep Eutectic Solvent and an Organic Solvent

Microwave-Assisted Extraction Combined with In-Capillary [Fe(ferrozine)3]2+-CE-DAD to Screen Active Components with the Ability to Chelate Ferrous Ions from Flos Sophorae Immaturus (Flos Sophorae)

Application of Ionic Liquids Based Microwave-Assisted Simultaneous Extraction of Carnosic Acid, Rosmarinic Acid and Essential Oil from Rosmarinus Officinalis

Hollow molecular imprinted polymers towards rapid, effective and selective extraction of caffeic acid from fruits

Mechanochemical-Assisted Extraction and Hepatoprotective Activity Research of Flavonoids from Sea Buckthorn (Hippophaë rhamnoides L.) Pomaces

Construction of [C4MIM]BF4 based in situ alkaline aqueous biphasic systems by NaOH for efficient extraction saponins from Xanthoceras sorbifolium Bunge leaves

Multi-objective optimization and extraction mechanism understanding of ionic liquid assisted in extracting essential oil from Forsythiae fructus

Development of an ionic liquid-based microwave-assisted method for simultaneous extraction and distillation for determination of proanthocyanidins and essential oil in Cortex cinnamomi.

An efficient approach for selective electromembrane extraction of benzoic and sorbic acids, and saccharin in soft drinks

Rapid Extraction of Yam Peel Total Flavonoids in A Cholinium-Based Magnetic Ionic Liquid Aqueous Biphasic System

Novel Microporous Membrane/Solvent Microextraction for Preconcentration of Cinnamic Acid Derivatives in Rhizoma Typhonii

Mechanochemical assisted extraction as a green approach in preparation of bioactive components extraction from natural products-A review