Abstract:A two-step process combining the (equilibrium) glucose isomerization to fructose with selective dehydration of fructose in the obtained sugar mixture to 5-hydroxymethylfurfural (HMF), where glucose is largely unconverted and recycled, represents an attractive concept to increase the overall efficiency for HMF synthesis. This work presents experimental and modelling studies on the conversion of such fructose-glucose mixture to HMF using the sulfuric acid catalyst in a water-methyl isobutyl ketone biphasic system under a wide range of conditions (e.g., temperature, catalyst and sugar concentrations). Through detailed product analyses and ESI-MS spectroscopy, the excess formation of formic acid (together with humins) by the direct sugar/HMF degradation was confirmed and included in the reaction network (neglected in most literatures). The kinetic modelling based on batch experiments in monophasic water well describes the measurements thereof, whereas distinct deviations were found in the prediction of typical literature kinetic models. The incorporation of HMF equilibrium extraction into the developed kinetic model, with consideration of phase volume change as a function of temperature and partial phase miscibility, enables to predict reaction results in the biphasic system in batch. This kinetic model allows to optimize conditions for HMF synthesis that are favored in continuous reactors with minimized back mixing. Based on the model implications, the biphasic system was optimized with slug flow microreactors to better address process intensification and scale-up aspects. Using a simulated fructose-glucose mixture feedstock to represent commercially available high fructose corn syrups, a maximum HMF yield of 81% was obtained at 155 °C over 0.05 M H2SO4 at a residence time of 16 min in the microreactor, with 96% fructose conversion and over 95% of glucose remaining unconverted.

Highly efficient production and purification of fructose via glucose isomerization by calcium chloride and triethylamine

Highly Efficient Hydrotalcite/1-Butanol Catalytic System for the Production of the High-Yield Fructose Crystal from Glucose

Calcium Chloride with Triethylamine Effectively Promoted the Preparation and Separation of High-Purity Fructose from Glucose

Highly Efficient and Selective Preparation of 5-Hydroxymethylfurfural from Concentrated Carbohydrates Using Deep Eutectic Solvents

Insight into the dehydration of high-concentration fructose to 5-hydroxymethylfurfural in oxygen-containing polar aprotic solvents

Conversion of Glucose to 5-Hydroxymethylfurfural in Deep Eutectic Solvent of Choline Chloride–Chromium Chloride

Ultra-Dilute SnCl4-Catalyzed Conversion of Concentrated Glucose to 5-Hydroxymethylfurfural in Aqueous Deep Eutectic Solvent.

Efficient Conversion of Fructose to 5-[(Formyloxy)methyl]furfural by Reactive Extraction and In-Situ Esterification

Triethylamine-catalyzed Isomerization of Glucose to Fructose under Low Temperature Conditions in Aqueous Phase

Chemical isomerization of glucose into fructose

Recent advance in isomerization of glucose

Glucose Isomerizes to Fructose Catalyzed by the Eco‐Friendly and Biodegradable Ionic Liquids

Interfacial Thermoconvection and Atomic Relay Catalysis Enable Equilibrium Shifting and Rapid Glucose‐to‐Fructose Isomerization

Highly efficient isomerization of glucose to fructose over a novel aluminum doped graphitic carbon nitride bifunctional catalyst

Fabrication of Mg-Al Hydrotalcite/carbon Nanotubes Hybrid Base Catalysts for Efficient Production of Fructose from Glucose

Selective fructose dehydration to 5-hydroxymethylfurfural from a fructose-glucose mixture over a sulfuric acid catalyst in a biphasic system: Experimental study and kinetic modelling

Highly Selective Biphasic System for the Cyclic Transformation of Glucose into 2,5-Bis(hydroxymethyl)furan Via Tandem Catalysis

Glucose Aqueous Isomerization Catalyzed by Basic Ionic Liquids

Aqueous Isomerization of Glucose to Fructose Catalyzed by Guanidinium Ionic Liquids

Chemical Isomerization of Glucose to Fructose Production

Acid‐Base Cascades in Zeotype Single Crystal for Sugar Conversion