Single‐Atom Ru Alloyed with Ni Nanoparticles Boosts CO2 Methanation
Tengfei Zhang,Peng Zheng,Jiajian Gao,Zhennan Han,Fangna Gu,Wenqing Xu,Lina Li,Tingyu Zhu,Ziyi Zhong,Guangwen Xu,Fabing Su
DOI: https://doi.org/10.1002/smll.202308193
IF: 13.3
2023-11-14
Small
Abstract:Ru single atoms anchored to the surface of Ni nanoparticles (NPs) via Ru1‐Ni coordination greatly facilitate CO2 methanation. In situ characterization and theoretical calculations show that the interfacial site of Ru1‐Ni facilitates the direct dissociation of CO2 and lowers the energy barrier for the hydrogenation of CO* intermediates, thus increasing the reaction rate of CO2 hydrogenation to CH4. Designing catalysts to proceed with catalytic reactions along the desired reaction pathways, e.g., CO2 methanation, has received much attention but remains a huge challenge. This work reports one Ru1Ni single‐atom alloy (SAA) catalyst (Ru1Ni/SiO2) prepared via a galvanic replacement reaction between RuCl3 and Ni nanoparticles (NPs) derived from the reduction of Ni phyllosilicate (Ni‐ph). Ru1Ni/SiO2 achieved much improved selectivity toward hydrogenation of CO2 to CH4 and catalytic activity (Turnover frequency (TOF) value: 40.00 × 10−3 s−1), much higher than those of Ni/SiO2 (TOF value: 4.40 × 10−3 s−1) and most reported Ni‐based catalysts (TOF value: 1.03 × 10−3–11.00 × 10−3 s−1). Experimental studies verify that Ru single atoms are anchored onto the Ni NPs surface via the Ru1–Ni coordination accompanied by electron transfer from Ru1 to Ni. Both in situ experiments and theoretical calculations confirm that the interface sites of Ru1Ni‐SAA are the intrinsic active sites, which promote the direct dissociation of CO2 and lower the energy barrier for the hydrogenation of CO* intermediate, thereby directing and enhancing the CO2 hydrogenation to CH4.
materials science, multidisciplinary,chemistry, physical,physics, applied, condensed matter,nanoscience & nanotechnology