Use of sawdust for production of ligninolytic enzymes by white-rot fungi and pharmaceutical removal

M. Hultberg,O. Golovko

DOI: https://doi.org/10.1007/s00449-024-02976-8

IF: 3.434

2024-03-15

Bioprocess and Biosystems Engineering

Abstract:Use of white-rot fungi for enzyme-based bioremediation of wastewater is of high interest. These fungi produce considerable amounts of extracellular ligninolytic enzymes during solid-state fermentation on lignocellulosic materials such as straw and sawdust. We used pure sawdust colonized by Pleurotus ostreatus , Trametes versicolor , and Ganoderma lucidum for extraction of ligninolytic enzymes in aqueous suspension. Crude enzyme suspensions of the three fungi, with laccase activity range 12–43 U/L and manganese peroxidase activity range 5–55 U/L, were evaluated for degradation of 11 selected pharmaceuticals spiked at environmentally relevant concentrations. Sulfamethoxazole was removed significantly in all treatments. The crude enzyme suspension from P. ostreatus achieved degradation of wider range of pharmaceuticals when the enzyme activity was increased. Brief homogenization of the colonized sawdust was also observed to be favorable, resulting in significant reductions after a short exposure of 5 min. The highest reduction was observed for sulfamethoxazole which was reduced by 84% compared to an autoclaved control without enzyme activity and for trimethoprim which was reduced by 60%. The compounds metoprolol, lidocaine, and venlafaxine were reduced by approximately 30% compared to the control. Overall, this study confirmed the potential of low-cost lignocellulosic material as a substrate for production of enzymes from white-rot fungi. However, monitoring over time in bioreactors revealed a rapid decrease in enzymatic ligninolytic activity.

engineering, chemical,biotechnology & applied microbiology

What problem does this paper attempt to address?

The paper primarily explores the use of ligninolytic enzymes produced by white-rot fungi cultivated on sawdust, particularly laccase and manganese peroxidase, to degrade pharmaceutical residues in water.

The research background lies in the fact that many everyday chemicals, such as pharmaceuticals, are designed to produce biological effects at low concentrations, and these compounds often have persistence, eventually entering wastewater systems. Traditional wastewater treatment plants have limited capacity to remove these compounds, making it necessary to explore new removal methods. Among them, enzyme-based bioremediation technologies have gained attention due to their energy efficiency, environmental friendliness, and high efficiency in treating low-concentration pollutants.

Specifically, this paper studied the laccase and manganese peroxidase activities produced by three common white-rot fungi—Pleurotus ostreatus, Trametes versicolor, and Ganoderma lucidum—when cultivated on a sawdust substrate, and evaluated the degradation effects of these crude enzyme extracts on 11 common pharmaceuticals, including sulfamethoxazole. The experimental results showed that all treatment groups significantly reduced the concentration of sulfamethoxazole. By increasing the enzyme activity produced by Pleurotus ostreatus, the range of degradable pharmaceuticals can be further expanded. Additionally, brief homogenization treatment also helps to improve degradation efficiency.

However, the study also found that in continuous flow bioreactors, the enzyme activity produced by white-rot fungi rapidly declined over time, indicating that directly using sawdust colonized by white-rot fungi as a filtration material may not be the best choice for enhancing enzyme activity.

In summary, the study confirmed the potential of low-cost sawdust as a substrate for cultivating white-rot fungi to produce ligninolytic enzymes and validated the effectiveness of these enzymes in degrading specific pharmaceuticals. However, it also pointed out the technical challenges that need to be addressed in practical applications.