Utilization of Bidirectional Cation Transport in a Thin Film Composite Membrane: Selective Removal and Reclamation of Ammonium from Synthetic Digested Sludge Centrate via an Osmosis–Distillation Hybrid Membrane Process
Peizhi Wang,Ji Li,Xiaolei Zhang,Xinglin Lu,Qianliang Liu,Tao Zhang,Wei Cheng,Jun Ma
DOI: https://doi.org/10.1021/acs.est.0c01496
2020-07-24
Abstract:Selective removal and resource recovery of ammonium nitrogen (NH<sub>4</sub><sup>+</sup>–N) from high-strength ammonium waste streams is of practical importance for biological wastewater treatment and environmental protection. In this study, we demonstrate the simultaneous removal and reclamation of ammonium from synthetic digested sludge centrate via a novel osmosis-distillation hybrid membrane (ODHM) process. Using NaHCO<sub>3</sub> as the draw solute, ammonium diffuses from the synthetic centrate to the draw solution by utilizing the bidirectional cation transport nature of the thin film composite (TFC) membrane. Then, NH<sub>4</sub><sup>+</sup> is converted to gaseous NH<sub>3</sub> at 60 °C and recovered by a sweeping gas membrane distillation (SGMD) process. Herein, the bidirectional transport of monovalent cations in the osmotic process, selectivity of TFC membranes for different cations, and recovery of the draw solution following the extraction of ammonia through the SGMD process were systematically investigated. The removal of NH<sub>4</sub><sup>+</sup>–N from the synthetic centrate achieved 21.34% during a 6-h continuous operation of the ODHM system, with ammonium fluxes through the TFC and SGMD membranes at 1.39 and 0.57 mol m<sup>–2</sup> h<sup>–1</sup>, respectively. A secondary interfacial polymerization was proposed to further enhance ammonium transport through the TFC membrane. Results reported here highlight the potential of the ODHM process for the selective removal and reclamation of ammonium from ammonium-rich waste streams.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acs.est.0c01496?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acs.est.0c01496</a>.S1, Experimental protocol for selective removal and reclamation of ammonium nitrogen; S2, silver binding method; S3, supplemental description of analytical methods; S4, bidirectional transport of ions through the TFC membrane; Figure S1, schematic diagram of the lab-scale ODHM system; Figure S2, effect of NaHCO<sub>3</sub> background on the accuracy of NH<sub>4</sub><sup>+</sup>–N measurement; Figure S3, influence of NaHCO<sub>3</sub> background concentration on measurement accuracy during ICP-OES analysis of K<sup>+</sup>, Ca<sup>2+</sup>, and Mg<sup>2+</sup>; Figure S4, fluxes of reverse and forward transported ions in the osmotic process; Figure S5, specific salt flux (SFF) for cations of the TFC membrane; Figure S6, conductivity, pH, water flux, and the ammonium concentration in centrate as a function of experimental time during the treatment of synthetic centrate by ODHM process; Figure S7, SSF for NH<sub>4</sub><sup>+</sup> of the TFC pristine and modified membranes; Table S1, brief summary of biological treatments, chemical/physical extractions, and membrane processes on ammonium removal; Table S2, composition and pH of the feed and draw solutions for the experiments in <a class="internalNav" href="#fig1">Figure </a><a class="internalNav" href="#fig1">1</a>B; and Table S3, composition of the feed and draw solutions for the experiments in <a class="internalNav" href="#fig1">Figure </a><a class="internalNav" href="#fig1">1</a>E (<a class="ext-link" href="/doi/suppl/10.1021/acs.est.0c01496/suppl_file/es0c01496_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.
environmental sciences,engineering, environmental