On the treatment of nanofiltration concentrates of mature landfill leachate by air humidification-dehumidification technology
Fang-fang CHEN,Han L(U),You-zhou ZHOU,Neng FAN,Zhi-tong YAO,Mei-sheng XIA
DOI: https://doi.org/10.13637/j.issn.1009-6094.2017.06.052
2017-01-01
Abstract:The paper intends to introduce a treating method for the landfill leachate from a nanofiltrating (NF) unit through the air humidification-dehumidification (HD) process,and study the effects of different pH values on the removing efficiencies of COD,TOC,UV254,and NH3-N.In the said air HD process,it is expected for the heat and mass transfer to take place between the nanofiltration (short for NF) condensate and the air on the package surface,while the water steam can be transferred from the NF condensate to the air and then subsequently condensed.The results of our test show that the volumetric heat transfer velocity and the water-producing rate can be made to increase up to 236 kW/m3 and 8.11 kg/h on the condition that the NF condensate and the air flowing rates are to be as high as 240 L/h and 200 m3/h,respectively.Then,pH values of NF condensate can be regulated to those of 3.11,5.23,and 9.14 by adding NaOH or H2SO4 to the solution.As a result,it can be found that,COD removal rate may tend to get higher under the alkaline condition than under the acidic one,whereas the removal rate for NH3-N tends to decrease with the increase of pH value.More specifically speaking,the removal rate of UV254 can be made as high as about 98.0 ％ at various pH values with the removal rate of TOC reaching its maximum one hour later at pH value of 3.11.More exactly speaking,the maximum removal rates for COD,NH3-N,TOC,and UV254 should respectively be increased as high as 98.15％,97.9％,99.0％,and 99.0％,whereas the mass concentrations of NH3-N,COD,TOC,and the absorbance of UV254 in the condensate may have dropped to 1.95 mg/L,32.00 mg/L,7.00 mg/L,and 0.037 cm-1,in respective accordance.Therefore,the condensating water quality should be able to attain the acceptable discharge limits.Therefore,as compared to the evaporation method,the air HD technology here introduced can be expected to exhibit highly promising economic feasibility,whereas the HD process can be regarded as an effective way to treat the NF condensate.