Abstract:This study investigated the feasibility of applying an anaerobic step-feeding strategy to enhance the performance of granular sequencing batch reactors (GSBRs) in terms of operational stability of the cultivated mature granules and nutrient removal efficiencies. Two identical 5 L reactors were operated with a total cycle time of 8 h. GSBRs were operated with high-strength synthetic wastewater (COD = 1250 ± 43, ammonium (NH4-N) = 115.2 ± 4.6, and orthophosphate (PO4-P) = 17.02 ± 0.9 mg/L) for 360 days through three stages: (1) Cultivation, 125 days (>2.1 mm); (2) Maturation, 175 days (>3 mm); (3) alternate feed loading strategy for R2 only for 60 days (anaerobic step-feeding). The granulation process, the physical properties of the granules, the nutrients, and the substrate removal performance were recorded during the entire operational period. For the cultivation and maturation stages, both reactors followed the fast single feeding mode followed by anaerobic mixing, and the results indicated a strong correlation between R1 and R2 due to the same working conditions. During the cultivation stage, adopting high organic loading rate (OLR) at the reactor start-up did not accelerate the formation of granules. Removal efficiency of PO4-P was less than 76% during the maturation period, while it exceeded 90% for COD, and was higher than 80% for NH4-N without effect of nitrite or nitrate accumulations due to simultaneous nitrification–denitrification. After changing filling mode for R2 only, there was unexpected deterioration in the performance and a rapid disintegration of the matured granules (poor settleability) accompanied by poor effluent quality due to high content of suspended solids because of applying selection pressure of short settling time. Consequently, GSBRs operation under the effect of fast single feeding mode followed by anaerobic mixing favors stable long-term granule stability.

Two-stage sequencing batch reactors with added iron shavings for nutrient removal and aerobic sludge granulation treating real wastewater with low carbon to nitrogen ratios

A Case for Aerobic Sludge Granulation: from Pilot to Full Scale

Adding waste iron shavings in a pilot-scale two-stage SBRs to develop aerobic granular sludge treating real wastewater

Formation and Characteristics of Aerobic Granular Sludge for Simultaneous Phosphorus and Nitrogen Removal in a SBR

A novel two-stage aerobic granular sludge system for simultaneous nutrient removal from municipal wastewater with low C/N ratios

Formation of Aerobic Granular in Pilot-scale SBR for Real Wastewater Treatment

A Reformed SBR Technology Integrated with Two‐step Feeding and Low‐intensity Aeration for Swine Wastewater Treatment

Experimental Research on Removal of Nitrogen and Phosphorus in Enhanced Sequencing Batch Reactor Activated Sludge Process

Aerobic Granules Cultivated with Simultaneous Feeding/draw Mode and Low-Strength Wastewater: Performance and Bacterial Community Analysis.

Adding waste iron shavings in reactor to develop aerobic granular sludge and enhance removal of nitrogen and phosphorus

Enhanced Biological Nutrient Removal in Sequencing Batch Reactors Operated As Static/oxic/anoxic (SOA) Process

Feasibility Study of Applying Anaerobic Step-Feeding Mode for the Treatment of High-Strength Wastewater in Granular Sequencing Batch Reactors (GSBRs)

Development of a 2-sludge, 3-stage system for nitrogen and phosphorous removal from nutrient-rich wastewater using granular sludge and biofilms

Enhanced Simultaneous Nitrogen and Phosphorus Removal Performance of the AGS-SBR Reactor Based on the Effects of the C/N Ratio and Microbial Community Change

Aerobic granules formation and simultaneous nitrogen and phosphorus removal treating high strength ammonia wastewater in sequencing batch reactor

Partial Nitrification and Enhanced Biological Phosphorus Removal in a Sequencing Batch Reactor Treating High-Strength Wastewater

Effect of COD/N ratio on cultivation of aerobic granular sludge in a pilot-scale sequencing batch reactor

Granulation of Activated Sludge in A Pilot-Scale Sequencing Batch Reactor for the Treatment of Low-Strength Municipal Wastewater

Aerobic Sludge Granulation in a Full-Scale Sequencing Batch Reactor

Characteristics of aerobic granule and nitrogen and phosphorus removal in a SBR

Microbial composition and nitrogen removal pathways in a novel sequencing batch reactor integrated with semi-fixed biofilm carrier: evidence from a pilot study for low- and high-strength sewage treatment