Abstract:This study aimed to investigate the liquid–liquid equilibrium (LLE) behavior of sesame fatty acid ethyl ester (FAEE) and methyl ester (FAME) in combination with glycerol and the co-solvents ethanol and methanol. FAEE and FAME were produced through the transesterification of mechanically extracted and purified sesame oil, using potassium hydroxide (KOH) as a homogeneous base catalyst. The reactions were conducted in ethanol and methanol to produce FAEE and FAME, respectively. Post-reaction, the products were separated and purified, followed by an analysis of the LLE behavior at 313.15 K and 323.15 K under atmospheric pressure (101.3 kPa). The experimental process for the miscibility analysis utilized a jacketed glass cell adapted for this study. Miscibility limits or binodal curves were determined using the turbidity-point method. Tie lines were constructed by preparing mixtures of known concentrations within the two-phase region, which allowed the phases to separate after agitation. Samples from both phases were analyzed to determine their composition. This study revealed that higher temperatures promoted greater phase separation and enhanced the biodiesel purification process. The NRTL model effectively correlated the activity coefficients with the experimental data, showing good agreement, with a root-mean-square deviation of 3.5%. Additionally, the data quality was validated using Marcilla's method, which yielded an R2 value close to 1. Attraction factors and distribution coefficients were also calculated to evaluate the efficiency of the co-solvents as extraction agents. The findings indicated higher selectivity for methanol than for ethanol, with varying degrees of distribution among the co-solvents. These results offer significant insights into enhancing biodiesel production processes by considering the effects of co-solvents on the LLE properties of mixtures, ultimately contributing to more efficient and cost-effective biodiesel production.

Enhanced Glycerolysis of Fatty Acid Methyl Ester by Static Mixer Reactor

Preparation of Fatty Acid Methyl Ester Catalyzed by Solid Acid from By- Products of Plam Oil

Co-liquefaction of swine manure and crude glycerol to bio-oil: model compound studies and reaction pathways.

Kinetics of glycerol esterification reaction

Fatty Acid Methyl Ester Synthesis through Transesterification of Palm Oil with Methanol in Microchannels: Flow Pattern and Reaction Kinetics

Lipase-catalyzed solvent-free synthesis of monoglycerides from biodiesel-derived crude glycerol: Optimized using response surface methodology

Transesterification of Methyl Oleate for Sustainable Production of Biolubricant: Process Optimization and Kinetic Study

Esterification of Free Fatty Acids in a Rotor-Stator Spinning Disc Reactor

Biolubricant Production of 2‐ethylhexyl Palmitate by Transesterification over Unsupported Potassium Carbonate

Preparation of fatty acid methyl esters for gas-chromatographic analysis of lipids in biological materials

Glycerol carbonate synthesis via transesterification of enriched glycerol and dimethyl carbonate using a Li-incorporated MCM-41 framework

Effect of reaction conditions in the catalytic esterification of palm fatty acid distillate to produce fatty acid methyl ester

Effect of fatty acid methyl ester on the mass transfer and rate of an acid transesterification reaction

Development of safe technology of obtaining fatty acid monoglycerides using a new catalyst

Methyl ester production process from palm fatty acid distillate using hydrodynamic cavitation reactors in series with solid acid catalyst

Kinetic modeling and optimization of the mono- and diglycerides synthesis mediated by the lipase Lipozyme® TL 100 L immobilized on clayey support

Improving the technology of the synthesis of fatty acid monoglycerides using the glycerolysis reaction

Liquid–Liquid Equilibrium of Sesame Fatty Acid (Ethyl and Methyl) Ester + Glycerol + Ethanol/Methanol Mixtures at Different Temperatures

Optimization and Kinetic Modeling of a Fed-Batch Fermentation for Mannosylerythritol Lipids (MEL) Production With Moesziomyces aphidis

Comparative study of catalytic conversion of glycerol, a by-product of transesterification, to cyclic hydrocarbons using MCM-22, ZSM-5 and alumina

Synthesis of glycerol‐free fatty acid methyl ester using interesterification reaction based on solid acid carbon catalyst derived from low‐cost biomass wastes