Abstract:The ejector refrigeration cycle (ERC) is often used as the sub-cycle of power and cooling cogeneration systems due to its advantages of simple structure design, few moving parts, less system investment, good stability and reliable operation. Considering the potential of organic Rankine cycle (ORC) in the utilization of low-grade heat, and the advantages of simple structure and many choices for working fluid, a novel power and cooling cogeneration system was designed, based on dual-pressure evaporation ORC (DORC) and ERC. In this system, a common condenser was used by DORC and ERC, and a part of working fluid separated from low-pressure steam generator outlet in DORC was used as the primary flow of ejector to drive ERC. A mathematical model for calculating the thermodynamic and thermoeconomic performances of the system was established. Sensitivity analysis was performed to determine the key parameters of the system, the results showed that the low-pressure evaporation temperature (TLPSG,out), high-pressure evaporation temperature (THP,E), vapor fraction of the low-pressure steam generator outlet (xLPSG,out) and working fluid mass flow ratio of high-pressure stage to low-pressure stage (k) were the four key parameters of the system. Parametric analysis showed that higher TLPSG,out and lower xLPSG,out were beneficial to increase the cooling output and thermal efficiency, while higher THP,E and larger k were helpful to increase the net power output and exergy efficiency. The net power output and exergy efficiency can be optimized by TLPSG,out and xLPSG,out. Using genetic algorithm (GA), multi-objective function optimization was carried out with THP,E, TLPSG,out, xLPSG,out and k as the decision variables. Moreover, the system's adaptability for working fluids R245fa, R236ea, R600, R600a, R601 and R601a was investigated. According to the optimization results, R236ea was the most suitable working fluid. When THP,E was 402.43K, TLPSG,out was 392.42K, xLPSG,out was 0.357 and k was 0.321, the calculated net power output , cooling output, thermal efficiency, exergy efficiency and total cost of unit exergy product (SUCP) were 273.00kW, 121.80kW, 14.52%, 44.03% and 42.62$/MWh, respectively. Exergy analysis was conducted using R236ea as working fluid. The results showed that the two steam generators and condenser were the main components responsible for most of the exergy destruction of the system in both basic case and optimized case. Compared to the basic case, the exergy destruction of the steam generators decreased by about 32.3%, and the total exergy destruction of the system decreased by about 5.0% in optimized case.

Performance improvement analysis of the regenerative dual-pressure organic flash cycle assisted by ejectors

Performance Study of an Enhanced Ejector Refrigeration Cycle with Flash Tank Economizer for Low-Grade Heat Utilization

Energy, Exergy, Economic Performance Investigation and Multi-Objective Optimization of Reversible Heat Pump-Organic Rankine Cycle Integrating with Thermal Energy Storage

Thermodynamic performance comparison of organic Rankine flash cycle with and without ejector for geothermal power output

Thermodynamic Analysis of Three Ejector Based Organic Flash Cycles for Low Grade Waste Heat Recovery

Synergetic mechanism of organic Rankine flash cycle with ejector for geothermal power generation enhancement

Effects of two-phase expander on the thermoeconomics of organic double-flash cycles for geothermal power generation

Parametric analysis and thermal-economical optimization of a parallel dual pressure evaporation and two stage regenerative organic Rankine cycle using mixture working fluids

Thermodynamic Analysis and Optimization of a Partial Evaporating Dual-Pressure Organic Rankine Cycle System for Low-Grade Heat Recovery

Ejector optimization and performance analysis of electric vehicle CO2 heat pump with dual ejectors

Off-design performance comparative analysis between basic and parallel dual-pressure organic Rankine cycles using radial inflow turbines

Experimental investigation on organic Rankine flash cycle with high- and low-stage scroll-expanders for thermal power generation

Thermodynamic and thermoeconomic performance analyses and optimization of a novel power and cooling cogeneration system fueled by low-grade waste heat

Thermodynamic and techno-economic performance comparison of two-stage series organic Rankine cycle and organic Rankine flash cycle for geothermal power generation from hot dry rock

Thermodynamic Analysis and Optimization of Four Organic Flash Cycle Systems for Waste Heat Recovery

Thermodynamic analysis and parametric optimization of ejector heat pump integrated with organic Rankine cycle combined cooling, heating and power system using zeotropic mixtures

Performance analyses of regenerative organic flash cycles for geothermal power generation

Transient Behavior Investigation of a Regenerative Dual-Evaporator Organic Rankine Cycle with Different Forms of Disturbances: Towards Coordinated Feedback Control Realization

Thermodynamic and Exergoeconomic Analysis of a Dual Expansion and Triple Recuperation Supercritical CO2 Power Cycle Driven by DME-oxygen Combustor

Off-Design Performance Comparative Analysis Between Dual-Pressure Organic Rankine Cycles Using Pure and Mixture Working Fluids

Performance Analysis and Optimization of a Combined Cooling and Power System Using Low Boiling Point Working Fluid Driven by Engine Waste Heat