Abstract:Gas explosion in connected vessels usually leads to high pressure and high rate of pressure increase which the vessels and pipes can not tolerate. Severe human casualties and property losses may occur due to the variation characteristics of gas explosion pressure in connected vessels. To determine gas explosion strength, an experimental testing system for methane and air mixture explosion in a single vessel, in a single vessel connected a pipe and in connected vessels has been set up. The experiment apparatus consisted of two spherical vessels of 350 mm and 600 mm in diameter, three connecting pipes of 89 mm in diameter and 6 m in length. First, the results of gas explosion pressure in a single vessel and connected vessels were compared and analyzed. And then the development of gas explosion, its changing characteristics and relevant influencing factors were analyzed. When gas explosion occurs in a single vessel, the maximum explosion pressure and pressure growth rate with ignition at the center of a spherical vessel are higher than those with ignition on the inner-wall of the vessel. In conclusion, besides ignition source on the inner wall, the ignition source at the center of the vessels must be avoided to reduce the damage level. When the gas mixture is ignited in the large vessel, the maximum explosion pressure and explosion pressure rising rate in the small vessel raise. And the maximum explosion pressure and pressure rising rate in connected vessels are higher than those in the single containment vessel. So whenever possible, some isolation techniques, such as fast-acting valves, rotary valves, etc., might be applied to reduce explosion strength in the integrated system. However, when the gas mixture is ignited in the small vessel, the maximum explosion pressures in the large vessel and in the small vessel both decrease. Moreover, the explosion pressure is lower than that in the single vessel. When gas explosion happens in a single vessel connected to a pipe, the maximum explosion pressure occurs at the end of the pipe if the gas mixture is ignited in the spherical vessel. Therefore, installing a pipe into the system can reduce the maximum explosion pressure, but it also causes the explosion pressure growth rate to increase. (C) 2013 Elsevier Ltd. All rights reserved.

Research on gas diffusion and explosion characteristics in a ship engine room

Numerical simulation and experimental study of gas diffusion in a ship engine room

Numerical Study of Hydrogen Leakage and Explosion in Hydrogen Refueling Station with Large Volume Hydrogen Storage Vessels

Numerical Investigation on Leakage and Diffusion Characteristics of Buried Hydrogen-Blended Natural Gas Pipelines

Hazard analysis by leakage and diffusion in Liquefied Natural Gas ships during emergency transfer operations on coastal waters

Experimental and Numerical Study of Natural Gas Leakage and Explosion Characteristics.

Numerical simulation of hydrogen leakage and diffusion in a ship engine room

The effect of concentration gradient on overpressure hazards and flame behavior of gas explosion in a vessel-duct connected device

Experimental Investigation of Gas Explosion in Single Vessel and Connected Vessels

Research on Natural Gas Leakage Diffusion of Urban Underground Pipeline and its Explosion Hazard

Quantitative risk assessment of a spill fire caused by the continuously leaked fuel in a sealed ship engine room

Experimental and numerical study on natural gas explosion evolution in open space under different initial conditions

Experimental Investigation And Numerical Simulation Of Gas Explosion In Linked Vessels

Experimental and numerical study of gas explosion from semi-submersible platform

Research on overpressure hazards and flame propagation behaviors of CH4/air mixture explosions in a vessel-duct connected device

Process Of Natural Gas Explosion In Linked Vessels With Three Structures Obtained Using Numerical Simulation

Quantitative Analysis of Leakage Consequences of LNG Ship-to-Ship Bunkering Based on CFD

Numerical Simulation on Gas Dispersions and Vapor Cloud Explosions Induced by Gas Released from an Ethylene Storage Tank

Numerical study on the temporal and spatial distribution law of natural gas explosion load on an ultra-deepwater semi-submersible drilling platform

Experimental study on gas explosion and venting process in interconnected vessels

Experimental study and a numerical analysis of the effects of vessel size on the gas explosion in a spherical one connected to the pipes