Abstract:A voltage degradation model for the low-pressure proton exchange membrane fuel cell (PEMFC) stack used in a fuel cell bus is presented: (1) the oxygen concentration term was derived from the PEMFC output voltage equation, and the concept of oxygen concentration resistance coefficient was introduced; (2) a 5kW low-pressure PEMFC stack was used in this study. Two similar tests were carried out before and after the stack operating in the driving cycle for 640h. First, the ohmic losses under different temperatures were measured using the current interrupt method and formulized with linear fitting method. Then, the oxygen concentration term was studied by the experiments with different air stoichiometric ratios while keeping the other operating parameters unchanged. The oxygen concentration resistance coefficient was obtained from the difference of voltages for the PEMFC stack in different air stoichiometric ratios using the genetic optimization algorithm. Then, the activation loss was obtained based on the PEMFC output voltage, the ohmic loss, and the concentration loss. The degradation model of the stack was built finally by comparing the two test results; (3) the correlation of the model to the actual experimental data is good; (4) the overvoltage of the stack with aging was analyzed using this model. The analysis showed that the activation overvoltage dominated the stack loss with about 80% of the total losses, followed by the ohmic loss. The concentration loss almost does not change with aging in the driving cycle condition; (5) the comparison of the simulation with the actual data from the PEMFC bus running for 30,000km indicated that after 36,000km the rated power of the PEMFC bus must be reduced.

A New Fuel Cell Degradation Model Indexed by Proton Exchange Membrane Thickness Derived from Polarization Curve

Degradation Differences of a Single Proton Exchange Membrane Fuel Cell: Energy Management Strategy and Dynamic Programming

A novel approach based on semi-empirical model for degradation prediction of fuel cells

Insight into the evolution of membrane chemical degradation in proton exchange membrane fuel cells:From theoretical analysis to model developing

Empirical Degradation Models of the Different Indexes of the Proton Exchange Membrane Fuel Cell Based on the Component Degradation

Investigation of Dynamic Driving Cycle Effect on Performance Degradation and Micro-Structure Change of PEM Fuel Cell

Numerical Analysis of PEMFC Stack Performance Degradation Using an Empirical Approach

A Comparative Study of Using Polarization Curve Models in Proton Exchange Membrane Fuel Cell Degradation Analysis

Understanding dynamic behavior of proton exchange membrane fuel cell in the view of internal dynamics based on impedance

Modeling Water and Thermal Transients Inside Proton Exchange Membrane for Vehicle Application Fuel Cells

Proton exchange membrane fuel cell degradation under close to open-circuit conditions

A refined grey Verhulst model for accurate degradation prognostication of PEM fuel cells based on inverse hyperbolic sine function transformation

Health Status Analysis of PEMFCs Based on Degradation Mechanism Model and Data-Driven Method

Modelling the membrane decomposition induced recoverable performance loss of proton exchange membrane fuel cells

Numerical Modeling of Liquid Water Transport Inside and Across Membrane in PEM Fuel Cells

Dynamic Modeling of Pt Degradation and Mitigation Strategies in Polymer Electrolyte Membrane Fuel Cells

A novel degradation model of proton exchange membrane fuel cells for state of health estimation and prognostics

Modeling of Catalyst Degradation in Polymer Electrolyte Membrane Fuel Cells Applied to Three‐Dimensional Computational Fluid Dynamics Simulation

Degradation identification and prognostics of proton exchange membrane fuel cell under dynamic load

A Semi-Empirical Voltage Degradation Model for A Low-Pressure Proton Exchange Membrane Fuel Cell Stack under Bus City Driving Cycles

Dynamic Current Cycles Effect on the Degradation Characteristic of a H2/O2 Proton Exchange Membrane Fuel Cell