Abstract:Two major challenges in fluid bed combustion of biomass are increased NOX emissions and bed agglomeration. Different additives were employed to simultaneously reduce NOX emissions and bed agglomeration from the fluidized bed combustion of biomass. The base fuel was straw, and the additives included CaO, kaolin, MgCO3, coal fly ash, clay, (NH4)2Fe(SO4)2, NH4Fe(SO4)2, (NH4)2SO4, NH4MgPO4, AlNH4(SO4)2, (NH4)2HPO4, (NH4)3[Fe(C2O4)3], and urea. The influence of (NH4)2SO4 particle size (<35 and <106 μm) and introduction method (batch addition or premixing with fuel) was additionally investigated. The most effective additives against NOX emissions and bed agglomeration were further studied in air staged straw combustion and unstaged sunflower husk combustion. During sunflower husk combustion, the influence of ash accumulation and incipient defluidization on NOX emissions were examined. The results show that kaolin, CaO, MgCO3, (NH4)2Fe(SO4)2, NH4Fe(SO4)2, AlNH4(SO4)2, and NH4MgPO4 prevented defluidization during straw combustion under the investigated conditions. Of these, AlNH4(SO4)2 and NH4MgPO4 reduced the fuel-N to NO conversion by 40%. The mechanism of reduction was related to the facilitation of thermal DeNOX reactions by the introduction of NH3-releasing additives. However, the NH-based additives resulted in higher emissions of N2O. The size of (NH4)2SO4 particles had a slight influence on the defluidization tendency and nitrogen chemistry, while no significant difference was observed between the two additive introduction methods. Air staging reduced the fuel-N to NO conversion by 40% during straw combustion. The use of NH4MgPO4 and AlNH4(SO4)2 under air staged conditions increased the NO emission slightly. This was predominantly caused by the combustion of NH3 in the secondary air jet. In the case of unstaged sunflower husk combustion, NH4MgPO4 and AlNH4(SO4)2 prevented defluidization while reducing the conversion of fuel-N to NO by 30%. During sunflower husk combustion, the accumulation of ash increased NO and decreased NH3 concentrations above the bed. This was related to the poor mixing as the bed approached defluidization and to the catalytic effect of ash forming elements on the oxidation of NH3 to NO.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acs.energyfuels.1c01186?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acs.energyfuels.1c01186</a>.Information on axial reactor temperature profiles, Experiment repeatability, TGA of de-NOX additives, CO and CXHY local concentrations, pressure drop across bed during sunflower husk combustion, and figures of temperature profiles, axial NO, N2O, NH3, and CO profiles, weight loss data, decomposition products, axial CH2O, CH4, C3H6, C3H8, C2H2, C2H4, C2H6, SO2, SO3, and H2SO4 profiles, and pressure drop (<a class="ext-link" href="/doi/suppl/10.1021/acs.energyfuels.1c01186/suppl_file/ef1c01186_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

Influence of Oxygen Carrier on NOx and N2O Emissions in Biomass Combustion Within Fluidized Beds

NOx and SO2 Emission of Oxygen Carrier Aided Combustion in Fluidized Bed

No and N2o Emissions During Devolatilization and Char Combustion of A Single Biomass Particle under Oxy-Fuel Conditions at Fluidized Bed Temperature

Experimental study of the NO and N2O emissions during devolatilization and char combustion of a single biomass particle in O2/N2 and O2/H2O under low temperature condition

Oxygen-Carrier-Aided Combustion in a Bench-Scale Fluidized Bed

Experimental Study on the NO and N2O Formation Characteristics During Biomass Combustion

Experimental Study Of The Combustion And No Emission Behaviors During Cofiring Coal And Biomass In O-2/N-2 And O-2/H2o

Improvement of coal and Petroleum coke combustion in a fluidized bed by using ilmenite ore as bed material

Interactions in NOX chemistry during fluidized bed co-combustion of residual biomass and sewage sludge

NOx Emission Characteristics of Coal and Biomass Co-firing in O2/CO2 Atmosphere

Progress in Catalytic Decomposition and Removal of N2O in Fluidized Bed

Pollutant Emissions during Oxy-Fuel Combustion of Biomass in a Bench Scale CFB Combustor

Multifunctional Additives for NO X Abatement in Fluidized Bed Biomass Combustion

Experimental and Numerical Investigation of the Combustion Characteristics and NO Emission Behaviour During the Co-Combustion of Biomass and Coal

Improved Fuel Conversion Through Oxygen Carrier Aided Combustion During Incineration of Biomass-Based Solid Waste in a Rotary Kiln

Nitrogen transformation during pressurized oxy-biomass combustion process

An experimental investigation into the fate of fuel-bound N-species during fluidised bed combustion of a dried coal slime in O 2 /Ar mixtures

Experimental study on NOx emission characteristics under oxy-fuel combustion

Experimental Study of Nitrogen Conversion During Char Combustion under a Pressurized O2/H2O Atmosphere

Effect of Reaction Conditions on Nitrogen Conversion During Char-O2/NO Combustion