Abstract:Background: Microalgae have attracted considerable interest due to their ability to produce a wide range of valuable compounds. Pulsed Electric Fields (PEF) has been demonstrated to effectively disrupt the microalgae cells and facilitate intracellular extraction. To increase the commercial viability of microalgae, the entire biomass should be exploited with different products extracted and valorized according to the biorefinery scheme. However, demonstrations of multiple component extraction in series are very limited in literature. This study aimed to develop an effective lipid extraction protocol from wet Scenedesmus almeriensis after PEF-treatment with 1.5 MJ·kgDW-1. A cascade process, i.e., the valorization of several products in row, was tested with firstly the collection of the released carbohydrates in the water fraction, then protein enzymatic hydrolysis and finally lipid extraction. Biomass processed with high pressure homogenization (HPH) on parallel, served as benchmark. Results: Lipid extraction with ethanol:hexane (1:0.41 vol/vol) offered the highest yields from the different protocols tested. PEF-treatment promoted extraction with almost 70% of total lipids extracted against 43% from untreated biomass. An incubation step after PEF-treatment, further improved the yields, up to 83% of total lipids. Increasing the solvent volume by factor 2 offered no improvement. In comparison, extraction with two other systems utilizing only ethanol at room temperature or elevated at 60 °C were ineffective with less than 30% of total lipids extracted. Regarding cascade extraction, carbohydrate release after PEF was detected albeit in low concentrations. PEF-treated samples displayed slightly better kinetics during the enzymatic protein hydrolysis compared to untreated or HPH-treated biomass. The yields from a subsequent lipid extraction were not affected after PEF but were significantly increased for untreated samples (66% of total lipids), while HPH displayed the lowest yields (~ 49% of total lipids). Conclusions: PEF-treatment successfully promoted lipid extraction from S. almeriensis but only in combination with a polar:neutral co-solvent (ethanol:hexane). After enzymatic protein hydrolysis in cascade processing; however, untreated biomass displayed equal lipid yields due to the disruptive effect of the proteolytic enzymes. Therefore, the positive impact of PEF in this scheme is limited on the improved reaction kinetics exhibited during the enzymatic hydrolysis step.

Mechanistic Insights into Lipid Extraction from Wet Microalgae Using Hydrophobic Deep Eutectic Solvents under Hydrothermal Conditions

Current Progress and Future Perspective of Microalgae Biomass Pretreatment Using Deep Eutectic Solvents

Subcritical water extraction of lipids from wet algae for biodiesel production

Disintegration of wet microalgae biomass with deep-eutectic-solvent-assisted hydrothermal treatment for sustainable lipid extraction

Microwave-assisted extraction of lipids from microalgae using an ionic liquid solvent [BMIM][HSO4]

Efficient fractionation of microalgae biomass as a whole for biodiesel production enabled by deep eutectic solvent and water

Ionic Liquid Assisted Subcritical Water Promotes The Extraction Of Lipids From Wet Microalgae Scenedesmus Sp.

Exploring deep eutectic solvents for enhanced extraction of bio-active compounds from microalgae biomass

Optimization of a novel lipid extraction process from microalgae

Analysis of the lipid extraction performance in a cascade process for Scenedesmus almeriensis biorefinery

Subcritical N-Hexane/isopropanol Extraction of Lipid from Wet Microalgal Pastes of Scenedesmus Obliquus

Rapid extraction of lipid from wet microalgae biomass by a novel buoyant beads and ultrasound assisted solvent extraction method

Study of the Experimental and Microscopic Mechanism of the Removal of Phenolic Compounds from Wastewater Based on Hydrophobic Deep Eutectic Solvents

Selection of extraction solvents for edible oils from microalgae and improvement of the oxidative stability

Removal of Phenolic Compounds from Aqueous Solution Using Hydrophobic Deep Eutectic Solvent: Liquid-Liquid Phase Behavior and Intermolecular Interactions

Ultrasound‐Assisted Natural Deep Eutectic Solvents As Separation‐Free Extraction Media for Hydroxytyrosol from Olives

Solvent-free Lipid Extraction from Microalgal Biomass with Subcritical Water in a Continuous Flow Reactor for Acid-Catalyzed Biodiesel Production

Insights into the Liquid Extraction Mechanism of Actual High-Strength Phenolic Wastewater by Hydrophobic Deep Eutectic Solvents

Rational Screening of Deep Eutectic Solvents for the Direct Extraction of Α-Tocopherol from Deodorized Distillates

Microwave-assisted Three-Liquid-phase Salting-out Extraction of Docosahexaenoic Acid (Dha)-Rich Oil from Cultivation Broths of Schizochytrium Limacinium SR21

Extraction of Bioactive Compounds from C. vulgaris Biomass Using Deep Eutectic Solvents