Abstract:During high pressure processing, the adiabatic compression increase of food materials would cause non-uniform temperature distribution and heat transfer, which would also influence the inactivation of bacteria, spore, enzyme and the quality of foods. Thermal conductivity of food materials at high pressure is a very important parameter for understanding heat transfer and temperature variation during high pressure processing. Available data and measuring method of thermal conductivity of food materials under high pressure are still scarce. In this study, a thermal conductivity probe developed based on the line heat source theory was installed in a high pressure chamber to measure thermal conductivity of food materials under high pressure. The thermal conductivity probe was calibrated using 1.5% agar gel whose thermal conductivity was very close to that of pure water but the convective effect during the measurement was eliminated due to the gel network at pressure from 0.1 to 400 MPa with a pressure increment of 50 MPa. The results of calibration experiment indicated that thermal conductivity values of 1.5% agar gel measured under different pressures using the thermal conductivity probe were very close to that of reference data of pure water. Calibration factors defined as the ratio of measured and reference values of the thermal conductivity of 1.5% agar gel were found almost no effect by pressure. A general calibration coefficient value of 0.9944 (R square was 0.9997, observation number was 30) was obtained by linear regression analysis (zero intercept) of measured thermal conductivity values of 1.5% agar gel against reference values of pure water. The coefficient value was used for the correction of all experimental results in the following. Thermal conductivities of egg white, egg yolk, ham sausages and cream were measured at pressure from 0.1 to 400 MPa with a pressure increment of 50 MPa. The results demonstrated that the thermal conductivities of these selected food materials at high pressure conditions were higher (up to 28%) than that of the sample at the atmospheric pressure conditions and had a tendency to increase with increasing pressure. Results at atmospheric pressure in this study were compared to estimate values using empirical equation based on water content. The measured thermal conductivities of egg yolk (0.43 W/(m·℃)), ham sausages (0.45 W/(m·℃)) and cream (0.49 W/(m·℃)) were very close to the estimated values (egg yolk 0.40 W/(m·℃), ham sausages 0.43 W/(m·℃), cream 0.41 W/(m·℃)) , while the measured value of egg white (0.65 W/(m·℃)) was significantly higher than that of the estimated value (0.53 W/(m·℃)) as well as that of pure water. The reason probably was that the flowability of egg white caused the generation of convective heat transfer. Measured thermal conductivities of egg white decreased at pressure higher than 300 MPa which was different from other three materials. The reason probably was that the pressure processing more than 300 MPa induced coagulation of egg white resulting in decrease of flowability as well as convective heat transfer. The water content of food materials had a significant effect on thermal conductivity. In general, the higher the water content, the higher the thermal conductivity. This rule was also confirmed at high pressure as the thermal conductivity from highest to lowest in order being egg white (83.1% water) > ham sausages (63.5%) > cream (57.5%) > egg yolk (50.7%). An empirical equation was established for prediction of the thermal conductivity of food materials at high pressure. The fourth-order polynomial was used to fit the thermal conductivity values of egg white, egg yolk, ham sausages and cream at pressure range from 0.1 to 400 MPa with temperature of 25℃. The regression coefficients of these equations were all above 0.91. This study could provide basic scientific datas for high pressure processing of food materials.

Mass Transfer Dynamics During High Pressure Brining of Chicken Breast

Author Response for "combination Treatment of High‐pressure and CaCl 2 for the Reduction of Sodium Content in Chicken Meat Batters: Effects on Physicochemical Properties and Sensory Characteristics"

Ultra High Pressure Increasing Thermal Conductivity of Food Materials

Texture Changes of High Pressure Processed Fresh-Cut Carrots Combined Pretreatment

Effects of Different Thermal Temperatures on the Shelf Life and Microbial Diversity of Dezhou-braised Chicken.

Evaluation and comparison of thermal conductivity of food materials at high pressure

Effect of High Pressure Processing on Moisture Sorption Properties of Brown Rice

Effects of Thermal Processing on the Texture and Collagen Characteristics of Ready-to-eat Chicken Claw

Enhancement of Functional Properties of Rice Bran Proteins by High Pressure Treatment and Their Correlation with Surface Hydrophobicity

Dynamic changes of tenderness, moisture and protein in marinated chicken: the effect of different steaming temperatures

Improved duck meat quality by application of high pressure and heat: A study of water mobility and compartmentalization, protein denaturation and textural properties

Effects of High-Pressure Processing on the Cooking Loss and Gel Strength of Chicken Breast Actomyosin Containing Sodium Alginate

Research Progress of the Effect of Ultra-high Pressure Treatment on Chicken Meat Quality

Effects of Heating on Tenderness, Texture and Microstructure of Sanhuang Chicken Breast Meat

Effect of ultrasound assisted collagen peptide of chicken cartilage on storage quality of chicken breast meat

Effects of Ultra High Pressure Treat on the Properties of Myofibrillar Protein from Duck Muscle Containing Modified Starch

Effects of Ultra-High Pressure Thawing on San Huang Chicken Quality by Different Frozen Mothods

Improving Water Retention of Chicken Breast Meats by CaCl2 Combined with Pulsed Electric Fields

Effect of ultrasound combined with highland barley dietary fiber on gel properties of reduced-salt chicken breast myofibrillar protein

Underlying formation mechanisms of ultrasound-assisted brined porcine meat: The role of physicochemical modification, myofiber fragmentation and histological organization

Effects of Different Salt Ion Concentrations in Immersion Vacuum Cooling on the Qualities of Spiced Chicken Drumsticks