Abstract:In order to investigate the application of pressure shift freezing (PSF) on different meat products, fresh shrimp and porcine liver were frozen by PSF at 100 MPa (-8.4 degrees C), 150 MPa (-14 degrees C) and 200 MPa (-20 degrees C), as well as by conventional air freezing (CAF) at -20 degrees C and liquid immersion freezing (LIF) at -20 degrees C. Temperature profile of test samples were recorded during different freezing processes and phase transformations were calculated. Microstructures of the formed ice crystals were analyzed for cross-section area, equivalent diameter, roundness and elongation. Size, shape and distribution of ice crystals were estimated and compared in different freezing processes. Results clearly showed that PSF is the more advantageous method. The phase transition times (2.97, 1.53 and 1.1 min in shrimp, and 2.47, 1.22 and 0.83 min in porcine liver, when subjecting to 100, 150 and 200 MPa PSF treatments, respectively) induced from the super-cooling attained in PSF treatments was much shorter than that in CAF (148 min in shrimp and 85 min in porcine liver) and LIF (5.9 and 5.5 min in shrimp and porcine liver, respectively). Small, regular and homogeneously distributed ice crystals were obtained in PSF treatments, especially at a higher pressure. The mean cross-section area of ice crystals formed in frozen shrimp was 2852, 1364 and 597 mu m(2) for PSF treatments at 100, 150, and 200 MPa, respectively, as compared with 151, 100 and 92 mu m(2) for frozen samples of porcine liver, respectively. The roundness of ice crystals in shrimp formed in PSFs was 0.87, 0.90 and 0.85, respectively, while the roundness of ice crystals in porcine liver was 0.87, 0.90 and 0.89, respectively. The size of ice crystals formed in PSF is pressure dependent, mainly due to a large super-cooling were created in a higher pressure of PSF. However, pressure does not play a major role in the shape of ice crystals. CAF created larger and irregular ice crystals due to the slow freezing rate, and LIF generated relatively smaller but irregular ice crystals, both of which resulted in irreversible damage to muscle tissue and caused degradation of product value. The results achieved in this research provides a better understanding of PSF process of shrimp and porcine liver, and PSF was proved as a promising freezing method for producing frozen products.Industrial relevance: This paper compares different freezing methods and their effect on thermal behavior and microstructure of meat muscle. Pressure shift freezing proved to be superior to conventional freezing regarding high degree of super-cooling, short phase transition time, and small, regular ice crystals. Different meat muscles, including shrimp and porcine liver, were also compared to investigate the effect of PSF on thermal behavior and microstructure. Interestingly, the ice crystals in porcine liver were much smaller than those in shrimp. Results obtained in the paper provide a better understanding of the PSF process and suggest that PSF is a superior method for freezing shrimp and porcine liver. (C) 2014 Elsevier Ltd. All rights reserved.

Characterizing High Pressure Phase Transitions of Gelatin Gel and Assessing Microstructural, Gel Properties, and Texture Changes Following Pressure Shift Freezing and Ice I to Ice III Phase Transition

Ice-crystal Formation in Gelatin Gel During Pressure Shift Versus Conventional Freezing

The Influence of Pressure-Shift Freezing Based on the Supercooling and Pressure Parameters on the Freshwater Surimi Gel Characteristics

Water Phase Transition under Pressure and Its Application in High Pressure Thawing of Agar Gel and Fish

Changes in Properties of Myofibrillar Protein and Myofibrillar Protein Gel from Freshwater Fish after Low-Temperature and High-Pressure Collaborative Treatment

The Impact of Pressure-Shift Freezing on the Three-Dimensional Network Structure and Properties of Myofibrillar Proteins in Surimi Gel Derived from Freshwater Fish

Insight into the Mechanism of Pressure Shift Freezing on Water Mobility, Microstructure, and Rheological Properties of Grass Carp Surimi Gel

Facilitation of Metastable Ice Ⅰ - Ice III Phase Transition of Liquid Foods at High-Pressure Sub-Zero Temperature by Perturbation

Effect of pressure-shift freezing treatment on gelling and structural properties of grass carp surimi

Facilitating high pressure phase-transition research and kinetics studies at subzero temperatures using self-cooling laboratory units.

Melting endothermic technique for establishing different phase diagram pathways during high pressure treatment of liquid foods

ICE CRYSTAL FORMATION IN PRESSURE SHIFT FREEZING OF ATLANTIC SALMON (SALMO SALAR) AS COMPARED TO CLASSICAL FREEZING METHODS

Thermal Characterization and Ice Crystal Analysis in Pressure Shift Freezing of Different Muscle (shrimp and Porcine Liver) Versus Conventional Freezing Method

Effects of Freezing on Quality Attributes of Surimi Gels with Various Cross-Linking Degrees Using MTGase: Quantitative Analysis Based on the Ice Crystals, Network Structure, and Taste Substances

Phase Separation Phenomena in Gelatin-Glucose Syrup Mixtures: Microstructures and Gel Characterization

Composition-antifreeze property relationships of gelatin and the corresponding mechanisms

Pressure dependence of the volume phase-transition of temperature-sensitive gels

Effect of freezing temperature on molecular structure and functional properties of gelatin extracted by microwave-freezing-thawing coupling method

Starch gelatinization under pressure studied by high pressure DSC

Investigating Texture and Freeze–Thaw Stability of Cold-Set Gel Prepared by Soy Protein Isolate and Carrageenan Compounding

Changes of Structural and Physical Properties of Semi-Gel from Alaska Pollock Surimi During 4 °C Storage