Abstract:The scope of this investigation aimed at obtaining and stabilizing bioactive products derived from Lycium barbarum seeds and peels, which were the byproducts in the processing of fruit juice. Zeaxanthin dipalmitate is a major carotenoid, comprising approximately 80% of the total carotenoid content in the seeds and peels. The method of obtainment was supercritical fluid CO2 extraction, studying different parameters that affect the oil yield and content of zeaxanthin dipalmitate. The optimized protocol to enact successful supercritical fluid CO2 extraction included optimum extraction pressure of 250 bar, temperature at 60 °C over a time span of 2.0 h, and a CO2 flow of 30 g/min, together with the use of a cosolvent (2% ethanol). The yields of oil and zeaxanthin dipalmitate under these optimal conditions were 17 g/100 g and 0.08 g/100 g, respectively. The unsaturated fatty acids were primarily linoleic acid (C18:2), oleic acid (C18:1), and γ-linolenic acid (C18:3), with their contents being as high as 91.85 ± 0.27% of the total fatty acids. The extract was a red-colored oil that was consequently microencapsulated through spray-drying with octenylsuccinate starch, gum arabic, and maltodextrin (13.5:7.5:3, w/w) as wall materials to circumvent lipid disintegration during storage and add to fruit juice in a dissolved form. The mass ratio of core material and wall material was 4:1. These materials exhibited the highest microencapsulation efficiency (92.83 ± 0.13%), with a moisture content of 1.98 ± 0.05% and solubility of 66.22 ± 0.24%. The peroxide content level within the microencapsulated zeaxanthin dipalmitate-rich oil remained at one part per eight in comparison to the unencapsulated oil, following fast-tracked oxidation at 60 °C for 6 weeks. This indicated the potential oxidation stability properties of microcapsule powders. Consequently, this microencapsulated powder has good prospects for development, and can be utilized for a vast spectrum of consumer health and beauty products.

Enhancing the Stability and Bio-Accessibility of Carotenoids Extracted from Canistel (lucuma Nervosa) Via Liposomes Encapsulation

Green Extraction of Carotenoids from Canistel (lucuma Nervosa) Pulps Using Ultrasound-Assisted Fatty Acid-Based Deep Eutectic Solvents: Optimization and Mechanism

Encapsulation of Lycopene Within Oil-in-water Nanoemulsions Using Lactoferrin: Impact of Carrier Oils on Physicochemical Stability and Bioaccessibility

Supercritical Fluid CO2 Extraction and Microcapsule Preparation of Lycium barbarum Residue Oil Rich in Zeaxanthin Dipalmitate

Physicochemical Properties and Bioavailability of Lutein Microencapsulation(LM)

Sodium Caseinate and Acetylated Mung Bean Starch for the Encapsulation of Lutein: Enhanced Solubility and Stability of Lutein

Encapsulation of Β-Carotene-loaded Oil Droplets in Caseinate/alginate Microparticles: Enhancement of Carotenoid Stability and Bioaccessibility

Carotenoid Bioaccessibility and Caco-2 Cell Uptake Following Novel Encapsulation Using Medium Chain Triglycerides

Developing biopolymer-stabilized emulsions for improved stability and bioaccessibility of lutein

Utilisation of flavonoids from <i>Lycium barbarum</i> L. leaves cross-linked with whey protein for the stabilisation and delivery of -carotene emulsions

Thermal-induced-stable High Internal Phase Emulsion for Lycopene Encapsulation and Delivery: Pre-heat Treatment Mediated Facilitation on the Isomerization, Stabilization, and Release of Lycopene

Recent technological strategies for enhancing the stability of lycopene in processing and production

Improved Stability and Controlled Release of Lycopene Via Self-Assembled Nanomicelles Encapsulation

Enhancing Lycopene Stability and Bioaccessibility in Homogenized Tomato Pulp Using Emulsion Design Principles

Modulation of the carotenoid bioaccessibility through liposomal encapsulation

Fabrication of nanoemulsion delivery system with high bioaccessibility of carotenoids from Lycium barbarum by spontaneous emulsification

Solvent-free Encapsulation of Β-Carotene in Natural Flaxseed Oil Bodies Induced Via Tepidity-Physical Field Treatment: Formation, Characteristic and Stability

Co‐encapsulation of Ω‐3 LC‐PUFAs and Carotenoids for Enhanced Synergistic Antioxidant Effects

Lutein encapsulated in whey protein and citric acid potato starch ester: Construction and characterization of microcapsules

Optimization of lycopene spray drying encapsulation in basil seed gum: Boosting bioavailability and mayonnaise stability

Development of Millettia Speciosa Champ Polysaccharide Conjugate Stabilized Oil-in-water Emulsion for Oral Delivery of Β-Carotene: Protection Effect and in Vitro Digestion Fate