Abstract:Previous studies suggested that Zintl phases related to the Ca9Zn4.5− δ Sb9 (0 δ x Cu x Sb9 indicated that they could achieve an optimized zT around 0.7. Especially for Ca9Zn4.5− δ Sb9, a very recent report suggested that a high zT of 1.1 at 875 K could be obtained in combination of various secondary phases introduced by the variation of Zn contents, which provided a chemical potential to change the composition. However, to change the composition of Ca9Zn4.5− δ Sb9 is actually very difficult to implement owing to the narrow homogeneity range. In this work, with Ca substituted by big cations such as Eu2+ and Sr2+, the unit cell of Ca9Zn4.5− δ Sb9 was expanded, and similar significant enhancement on the thermoelectric performance was resulted. All syntheses were handled inside a glovebox, then the reactants were loaded in the Nb tube and arc-welded, which were enclosed in a fused silica tube. The reactions were firstly heated to 1173 K in 6 h and then maintained at this temperature for 24 h. After the homogeneity process, the furnace was slowly cooled down to 873 K at a rate of 6 K/h, followed by another dwelling for 6 hours and finally cooled down to 573 K at a rate of 10 K/h. At last, the furnace was shut down and the reactions were opened in the glovebox. The compound were fully characterized by single-crystal X-ray diffraction (SXRD) and powder X-ray diffraction(PXRD), Energy dispersive spectrometer (EDS) and Hall effect measurement, etc. Single-crystal X-ray diffraction (SXRD) proves that with the increase of Sr component, the crystal parameters are slightly increasing. Hall effect measurement show that the substitution of Ca by Eu or Sr can both lead to an obvious decreasing on the carrier (holes) concentration, and the resultant mobility for Sr/Eu-doped materials is very similar if compared by the same doping level. It is also noted that neither the carrier concentration nor the mobility seems to vary linearly with the Eu/Sr-doping contents, which means a saturated state will be eventually approached. This phenomenon is consistent with the speculation above that the changes on the properties should predominantly originate from the change of interstitial Zn content, which the size effect dominated. While the decreasing carrier concentrations as well as the increasing mobility and lattice thermal conductivity all point to a structure modification, the crystal structures of these doped materials were systematically verified through the single crystal X-ray diffraction. In conclusion, although a direct measurement on such a small composition variation is very difficult (the X-ray diffraction results prove it), the significantly reduced carrier concentration and increased mobility as well as lattice thermal conductivity can still provide some useful hints on understanding the property optimization of these materials. For material Ca8.2Eu0.8Zn4.5− δ Sb9, high figure of merit with ZT ~0.81 has been achieved at 873 K.

Roles of Cu Doping in YbZn2Sb2 for Thermoelectric Performance Enhancement

Light Element Doping and Introducing Spin Entropy: an Effective Strategy for Enhancement of Thermoelectric Properties in BiCuSeO.

Thermoelectric Properties of Zn-Doped YbMg1.85−xZnxBi1.98

DOPING EFFECTS IN YBa2Cu1-xCox(Cu1-yZny)2Oz SYSTEM

Regulating thermoelectric properties of Eu0.5Ca0.5Zn2Sb2 through Mg dopant

Improved Thermoelectric Properties in Lu-Doped Yb14mnsb11 Zintl Compounds

Sr/Eu Cation Doping and Thermoelectric Properties of the Compound Ca9Zn4.5−δSb9 (0<Δ<0.5)

Effect of Ni Doping on the Thermoelectric Properties of YbCo2Zn20

Mechanism of Thermoelectric Performance Enhancement in CaMg2Bi2‐Based Materials with Different Cation Site Doping

Tuning the Thermoelectric Properties of Ca9zn4+Xsb9 by Controlled Doping on the Interstitial Structure

Thermoelectric performance improvement of p-type Mg3Sb2-based materials by Zn and Ag co-doping

Enhancing the effective mass and covalent bond strength of Cu 3 SbSe 4 -based thermoelectric materials by Mn/Sn co-doping

Doping Effect on Thermoelectric Properties of Nonstoichiometric AgSbTe 2 Compounds

Optimization of the thermoelectric performance of α-MgAgSb-based materials by Zn-doping

Tuning the Carrier Scattering Mechanism by Rare-Earth Element Doping for High Average zT in Mg 3 Sb 2 -Based Compounds

Enhancing Thermoelectric Performance of Yb 0.3 Co 4 Sb 12 by Synergistically Optimized Carrier Concentration and Ionized Impurity Scattering

Electronic Structures and Thermoelectric Properties of ZnSb Doped with Cd and in from First Principles Calculations

Enhanced Thermoelectric Performance of p-type AgSbTe2 via Cu Doping

Optimization of Carrier Concentration in Cu 22 Sn 10 S 32 through In- and Zn-Doping for Enhanced Thermoelectric Performance

Effects of Yttrium Doping on the Thermoelectric Properties of Hf0.6Zr0.4NiSn0.98Sb0.02 Half-Heusler Alloys

Effect of Zn-Doping on the Phase Transition Behavior and Thermoelectric Transport Properties of Cu2Se