Catalytic Degradation of Hexafluoropropylene Oxide Trimeric Acid During the Hydrothermal Regeneration of Spent Activated Carbon

Qianxin Zhang,Md Manik Mian,Aimin Zhang,Liang Zhou,Roujia Du,Wenya Ao,Gang Yu,Shubo Deng

DOI: https://doi.org/10.1021/acsestengg.4c00004

IF: 7.1

2024-01-01

ACS ES&T Engineering

Abstract:Regeneration of granular activated carbon (GAC) after adsorption of perfluoroalkyl and polyfluoroalkyl substances is an emerging challenge. This study reports a successful regeneration of spent GAC with hexafluoropropylene oxide trimer acid (HFPO-TA) at 120 degrees C. For the first time, we observed that GAC significantly catalyzed the degradation and defluorination of adsorbed HFPO-TA. The new catalytic degradation mechanism of HFPO-TA on GAC was proposed. Reaction intermediates' analysis confirmed that the ether group of HFPO-TA near the carboxyl group was first split into hexafluoropropylene oxide dimer acid (HFPO-DA) and trifluoroacetic acid (TFA). Subsequently, HFPO-DA was further broken down to produce PFPrA and TFA. These intermediates were detected only when HFPO-TA was adsorbed on GAC and were not found when HFPO-TA was dissolved in water without GAC. Bond dissociation energy calculations revealed that the ether group close to the carboxylic acid had a smaller dissociation energy and was more susceptible to ether group breakage compared to the decarboxylation reaction of HFPO-TA. The gas-phase products contained significant amounts of 1H-substituted HFPO-TA and 1H-substituted HFPO-DA, indicating the decarboxylation of HFPO-TA. Furthermore, density functional theory calculations indicated that the ether group in the HFPO-TA breakage site carried a more positive charge on GAC, facilitating the breakage through nucleophilic reaction. Finally, the regeneration efficiency of GAC remained at 81% at the fifth adsorption-degradation cycle. This study offers a novel and cost-effective strategy for the degradative regeneration of HFPO-TA-adsorbed GAC.