Abstract:The depletion of ore deposits, the increasing demand for raw materials, the need to process low-grade, complex and finely disseminated ores, and the reprocessing of tailings are challenges especially for froth flotation separation technologies. Even though they are capable of handling relatively fine grain sizes, the flotation separation of very fine and ultrafine particles faces many problems still. Further, the flotation of low-contrast semi-soluble salt-type minerals with very similar surface properties, many complex interactions between minerals, reagents and dissolved species often result in poor selectivity. This study investigates the flotation beneficiation of ultrafine magnesite rich in dolomite from desliming, currently reported to the tailings. The paper especially focuses on the impact of the depressant sodium hexametaphosphate (SHMP) on the following: (i) the froth properties using dynamic froth analysis (DFA), (ii) the separation between magnesite and dolomite/calcite, and (iii) its effect on the entrainment. As a depressant/dispersant, SHMP has a beneficial impact on the flotation separation between magnesite and dolomite. However, there is a trade-off between grade and recovery, and as well as the dewatering process which needs to be considered. When the SHMP increases from 200 g/t to 700 g/t, the magnesite grade increases from 67% to 77%, while recovery decreases massively, from 80% to 40%. The open circuit with four cleaning stages obtained a concentrate assaying 77.5% magnesite at a recovery of 45.5%. The dolomite content in the concentrate is about 20%, where 80% of dolomite was removed and importantly 98% of the quartz was removed, with only 0.3% of the quartz in the final concentrate. Furthermore, the application of 1-hydroxyethylene-1,1-diphosphonic acid (HEDP) as a more environmentally friendly and low-cost alternative to SHMP is presented and discussed. Using only 350 g/t of HEDP can achieve a similar grade (76.3%), like 700 g/t of SHMP (76.9%), while obtaining a 17% higher magnesite recovery as compared to 700 g/t of SHMP. Interestingly, the proportion of hydrophilic quartz minerals ending up in the concentrate is lower for HEDP, with only 1.9% quartz at a recovery of 21.5% compared to the 2.7% of quartz at a recovery of 24.9% when using SHMP. The paper contributes in general to understanding the complexity of the depressant responses in froth flotation.

Performance and Mechanism of Edtmpa As Inhibitor for Flotation Separation of Pyrite and Serpentine

Studies on the application of N,N-bis(phosphonomethyl)-sulfamic acid in the selective flotation separation of pyrite from serpentine

Application of organic phosphonic acid dispersant in the separation and flotation of chalcopyrite and serpentine

Ethylenediamine tetramethylenephosphonic acid as a selective collector for the improved separation of chalcopyrite against pyrite at low alkalinity

Original Data and Descriptions from Inhibition Mechanism of Ca2+, Mg2+ and Fe3+ in Fine Cassiterite Flotation Using Octanohydroxamic Acid

Depression Mechanism of a Novel Depressant on Serpentine Surfaces and Its Application to the Selective Separation of Chalcopyrite from Serpentine

Application of EDTMPS as a novel calcite depressant in scheelite flotation

Sedimentation of Fine Arsenopyrite with PEI and the Flotation Significance

Adsorption of Polyethyleneimine on Fine Arsenopyrite and the Effect on Its Xanthate Flotation

Enhancing the Flotation Separation of Galena and Pyrite in the Presence of Seawater

Highly selective flotation separation of chalcopyrite and pyrite by a novel dithiocarbamate collector with morpholine group

Flotation of Seafloor Massive Sulfide Ores: Combination of Surface Cleaning and Deactivation of Lead-Activated Sphalerite to Improve the Separation Efficiency of Chalcopyrite and Sphalerite

Insights into the flotation performance of ethylenediamine surface modified hemimorphite: Experimental and DFT study

Flotation performance and adsorption mechanism of 2-triethylenetetramine methylene-4-nonylphenol to pyrochlore

Investigating the Mechanism of Diethylenetriamine Pentamethylene Phosphonic Acid as a Depressant for Calcite Flotation of Fluorite

Flotation separation of chalcopyrite and pyrite via Fenton oxidation modification in a low alkaline acid mine drainage (AMD) system

Selective Inhibition Mechanisms of Fe(III) in the Flotation of Lepidolite

Improved flotation separation of sulfide minerals by synthesized surfactant based on para-position methyl effect

Enhanced collection of chalcopyrite by styrene-butyl acrylate polymer nanospheres in the presence of serpentine

Application of exopolysaccharides synthesized by Xanthomonas campestris in an efficient separation system of refractory chalcopyrite and molybdenite

Impact of Sodium Hexametaphosphate on the Flotation of Ultrafine Magnesite from Dolomite-Rich Desliming Tailings