Abstract:This paper reports an experimental investigation on the impact dynamics of liquid normal alkane (nheptane, n-decane and n-tetradecane) droplets on a stainless steel surface using high speed photography and long distance microscopic techniques. Particular interest is paid to comprehensively explore the effects of liquid viscosity and surface roughness on droplet spreading and bouncing dynamics at different thermal hydrodynamic impact regions. Specifically, firstly, high speed images identified four regimes (evaporation, nucleate boiling, transition boiling and film boiling regime) of physical phenomena that couple the droplet spreading hydrodynamics, heat transfer and phase change. Bubbles generation due to the heating of the surface with compression of air disk under the droplet was observed and this phenomenon is firstly promoted and then inhibited with the increase of the wall temperature until finally no bubbles were observed when wall temperature is beyond the Leidenfrost point (T-L). Rim disturbances during spreading were observed at relatively high Weber number with wall temperature higher than T-L. Increasing wall temperature reduces the rim disturbance. Secondly, the measured non-dimensional maximum spreading diameter beta(max) decreases with the increase of surface temperature until it becomes a constant when temperature is beyond T-L. Rough surface was found to have a lower T-L because of larger vapor pressure provided by more nucleation sites. Finally, for wall temperature beyond T-L, droplet bounces up after a certain period of residence time (tau(r)). It takes more time for droplet to rebound at larger We because of larger beta(max) takes longer time to retract and rebound. Both surface roughness and liquid viscosity showed no influence on time to reach beta(max) (tau(max)), but significantly increases tau(r) by slowing the retracting process, which both should be considered in future model of tau(r). (C) 2020 Elsevier Ltd. All rights reserved.

Study on Marangoni Explosion of Binary Mixtures in Liquid Layer

Study on Marangoni Explosion of Binary Mixtures in a Liquid Layer

Marangoni Convection Instability in an Evaporating Droplet Deposited on Volatile Liquid Layer

Experimental and Theoretical Investigation of Contact-Angle Variation for Water–ethanol Mixture Droplets on a Low-Surface-energy Solid

Molecular Dynamics Simulation On Spreading Of Mixture Nanodroplets On A Smooth And Homogeneous Surface

Shaping a Surface Microdroplet by Marangoni Forces along a Moving Contact Line of Four Immiscible Phases

Microdroplets nucleation by dissolution of a multicomponent drop in a host liquid

Analytical and Experimental Study on Boiling Vaporization and Multi-Mode Breakup of Binary Fuel Droplet

Marangoni-driven Spreading of a Droplet on a Miscible Thin Liquid Layer

Molecular Dynamics Simulation of Spreading of Mixture Droplets on Chemically Heterogeneous Surfaces.

Component Effects in Binary Droplet Impact Behaviors on the Heated Plate: Comparison Study of Ethanol/Propanol and Ethanol/Water Droplets and Observation of Novel Bubble Shrinkage Phenomenon

Liquid-Liquid Phase Separation Induced by Vapor Transfer in Evaporative Binary Sessile Droplets

Modeling unsteady Bénard-Marangoni instabilities in drying volatile droplets on a heated substrate

Marangoni-driven instability patterns of an N -hexadecane drop triggered by assistant solvent

Experimental and numerical study of droplet formation with Marangoni instability

Spreading and Bouncing of Liquid Alkane Droplets Upon Impacting on a Heated Surface

An experimental study of the vaporization, micro-explosion and ignition of single droplet on hot surface

Coupling between wetting dynamics, Marangoni vortices, and localized hot cells in drops of volatile binary solutions

Flow Patterns and Instabilities of Monodisperse Droplet Formation in a Microfluidic T-Junction Device

Combustion and microexplosion of collision-merged methanol/alkane droplets

Single Droplet with or Without Additives Impacting on High-Temperature Burning Liquid Pool