Abstract:The experiments presented here were based on the conclusions of our previous results. In order to avoid introduction of expression plasmid and to balance the NADH/NAD ratio, the NADH biosynthetic enzyme, i.e., NAD-dependent glyceraldehyde-3-phosphate dehydrogenase (GADPH), was replaced by NADP-dependent GADPH, which was used to biosynthesize NADPH rather than NADH. The results indicated that the NADH/NAD ratio significantly decreased, and glucose consumption and l-lysine production drastically improved. Moreover, increasing the flux through l-lysine biosynthetic pathway and disruption of ilvN and hom, which involve in the branched amino acid and l-methionine biosynthesis, further improved l-lysine production by Corynebacterium glutamicum. Compared to the original strain C. glutamicum Lys5, the l-lysine production and glucose conversion efficiency (α) were enhanced to 81.0 ± 6.59 mM and 36.45 % by the resulting strain C. glutamicum Lys5-8 in shake flask. In addition, the by-products (i.e., l-threonine, l-methionine and l-valine) were significantly decreased as results of genetic modification in homoserine dehydrogenase (HSD) and acetohydroxyacid synthase (AHAS). In fed-batch fermentation, C. glutamicum Lys5-8 began to produce l-lysine at post-exponential growth phase and continuously increased over 36 h to a final titer of 896 ± 33.41 mM. The l-lysine productivity was 2.73 g l−1 h−1 and the α was 47.06 % after 48 h. However, the attenuation of MurE was not beneficial to increase the l-lysine production because of decreasing the cell growth. Based on the above-mentioned results, we get the following conclusions: cofactor NADPH, precursor, the flux through l-lysine biosynthetic pathway and DCW are beneficial to improve l-lysine production in C. glutamicum.

Study on the Inducible Conditions of L-lysine Decarboxylase Produced by Hafnia Alvei

Optimization of bacteriocin production by a new Lactobacillus strain, ZJ317, using response surface methodology

Optimization of Medium Constituents for Ε-Poly-l-lysine Fermentation with Response Surface Methodology.

Optimization of Culture Conditions for Production of Cis-Epoxysuccinic Acid Hydrolase Using Response Surface Methodology

Optimization of fermentation conditions for production of a novel antifungal metabolite by response surface methodology

Optimization of fermentation conditions for xylanase production by engineered Pichia pastoris

Fermentation and Properties of Lysine Decarboxylase

Studies on the Fermentation Condition Optimization of Fibrinolytic Enzyme Produced by Armiilaria Luteo-virens Sacc

Optimization by Response Surface Methodology of Solid-state Fermentation Medium for α-Galactosidase Production by Aspergillus niger ZJUQH

Optimization of Culture Conditions for Enhanced Lysine Production Using Engineered Escherichia coli

Optimization of Rhamnolipid Hydrolysis Conditions Using Response Surface Methodology

Optimization of Fermentation for Production Conditions of Antibiotic by Bacillus amyloliquefaciens D1

Optimization of Fermentation Process for Recombinant Escherichia coli Expression of Phospholipase C

Optimization of fermentation conditions for polymalic acid production by Aureobasidium pullulans BK-10

Optimization of fermentation conditions for production of lactic acid by Lactobacillus delbrueckii

Response surface methodology as an approach for optimization of α-amylase production by the new isolated thermotolerant Bacillus licheniformis WF67 strain in submerged fermentation

Metabolic engineering Corynebacterium glutamicum for the l-lysine production by increasing the flux into l-lysine biosynthetic pathway

[Metabolic engineering of the substrate utilization pathway in Escherichia coli increases L-lysine production]

Optimization of Fermentation Conditions for Α-Chloropropionic Acid Dehalogenases Production Based on Response Surface Analysis

Artificial neural network and genetic algorithm coupled fermentation kinetics to regulate L-lysine fermentation

Statistical optimization of medium composition for alginate lyase production by Pseudoalteromonas tetraodonis strain QZ-4 using response surface methodology