Abstract:The aerodynamic performance of a reduced-scale coaxial rigid rotor system in hover and steady forward flights was experimentally investigated to gain insights into the effect of interference between upper and lower rotors and the influences of the advance ratio, shaft tilt angle and lift offset. The rotor system featured by 2 m-diameter, four-bladed upper and lower hingeless rotors and was installed in a coaxial rotor test rig. Experiments were conducted in the Φ3.2 m wind tunnel at China Aerodynamics Research and Development Center (CARDC). The rotor system was tested in hover states at collective pitches ranging from 0° to 13° and it was also tested in forward flights at advance ratios up to 0.6, with specific focus on the shaft tilt angle and lift offset sweeps. To ensure that the coaxial rotor was operating in a similar manner to that of the real flight, the torque difference was trimmed to zero in hover flight, whilst the constant lift coefficient was maintained in forward flight. An isolated single-rotor configuration test was also conducted with the same pitch angle setting in the coaxial rotor. The hover test results demonstrate that the figure of merit (FM) value of the lower rotor is lower than that of the upper rotor, and both are lower than that of the isolated single rotor. Moreover, the coaxial rotor configuration can contribute to better hover efficiency under the same blade loading coefficient (CT/σ). In forward flight, the effective lift-to-drag (L/De) ratio of the coaxial rigid rotor does not monotonously change as the advance ratio increases. Increases in the required power and drag in the case with a high advance ratio of 0.6 leads to the decreasing L/De ratio of the rotor. Meanwhile, the L/De ratio of the rotor is relatively high when the rotor shaft is tilted backward. The increasing lift offset tends to result in reduced required rotor power and an increase in the rotor drag. When the effect of the reduced rotor power is greater than that of the increased rotor drag, the L/De ratio increases as the lift offset increases. The L/De ratio can benefit significantly from lift offset at a high advance ratio, but it is much less influenced by lift offset at a low advance ratio. The forward performance efficiency of the upper rotor is poorer than that of the lower rotor, which is significantly different from the case in the hover flight.

Experimental Investigation on Aerodynamic Interactions of Canard Rotor/Wing Aircraft in Hover and Low Speed Forward Flight

Aerodynamic characteristics of hovering rotor/wing

A Wind Tunnel Study on Aerodynamic Characteristics of CRW Plane by the Rotor/wing

CFD Simulation of Unsteady Interaction Between Rotor and Fuselage for Canard Rotor Wing in Hovering Using Overset Grids

Flight dynamic characteristics of canard rotor/wing aircraft in hover

Design and Hover Test of Low Vibration Mach Scale Rotor with Twisted Composite Tailored Blade

Experimental Study to Quantify the Rotor-to-Rotor Interaction Characteristics of a Small Unmanned-Aerial-Vehicle

Flight Dynamics Characteristics of Canard Rotor/wing Aircraft in Helicopter Flight Mode

Flight Dynamic Modeling and Analysis for the Canard Rotor/Wing UAV

Wind Tunnel Studies on Hover and Forward Flight Performances of a Coaxial Rigid Rotor

Modeling and LPV flight control of the Canard Rotor/ Wing unmanned aerial vehicle

Flight Dynamics and Control of a New VTOL Aircraft in Fixed-wing Mode

Numerical study on aerodynamic performance of a ducted tail rotor in hover and sideward flight

Numerical simulation of aerodynamic interactions among helicopter rotor, fuselage, engine and body of revolution

A Study on the Aerodynamic Impact of Rotors on Fixed Wings During the Transition Phase in Compound-Wing UAVs

Investigation on the Aerodynamic Interaction Between a Rotor and Ship with Opened Hangar Door

Experimental Investigation of Lift Enhancement and Drag Reduction of Discrete Co-Flow Jet Rotor Airfoil

Controlled Canard Configuration Study for a Solid Rocket Motor Based Unmanned Air Vehicle

Aerodynamic Performance of Hovering Micro Revolving Wings in Ground and Ceiling Effects at Low Reynolds Number

Study on Aerodynamic Interaction of Rotor and Fuselage in Hover and Its Application to Flap Width Determination of Winged Helicopters

Experimental and Computational Investigation on Interaction Between Nano Rotor and Aerodynamic Rudder