Encapsulation of bacteria in different stratified extracellular polymeric substances and its implications for performance enhancement and resource recovery
Pian Zhao,Song Zhao,Hai-Guang Wang,Meng Lu,Zhi-Hua Li
DOI: https://doi.org/10.1016/j.watres.2022.118684
IF: 12.8
2022-06-02
Water Research
Abstract:Simultaneous recovery of biopolymers and enhanced bio-reactor performance are promising options for sustainable wastewater treatment, and the bioactivity of sludge after biopolymer extraction is thus critical for the performance of the system. To this end, stratified extracellular polymeric substances (EPS), including slime, loosely bound EPS (LB-EPS), and tightly bound EPS (TB-EPS), were extracted, and the bioactivities of the consequent extraction residues were assessed using aerobic respirogram, kinetic, and flow cytometry (FCM). After the initial weak extraction of slime, the particle size distribution of the sludge significantly decreased, and subsequent extractions of LB-EPS and TB-EPS produced an equivalent size distribution. In contrast, the fractal dimension decreased after each extraction, suggesting that LB-EPS and TB-EPS affected the compactness of flocs rather than the size. The aerobic bacteria distribution estimated using respirogram shows that slime mainly encapsulated heterotrophs while LB-EPS mainly encapsulated nitrifiers. In addition, the ammonia-nitrogen affinity coefficient decreased from 1.79 to 0.28 mg/L when slime was removed, thereby encouraging the activities of autotrophic nitrifiers. Further removal of LB-EPS induced high energy dispersion as the maintenance coefficient m and the metabolic dispersion index μ/m increased from 0.11 to 0.22 and 0.44 to 0.63, respectively. Meanwhile, the yield rate decreased from 0.77 to 0.66. Although pellets that resulted from TB-EPS extraction were not aerobically active as described by respirogram and growth curves, they were still metabolically active as measured by live/dead cell counting and redox sensor green signal. These pellets used more energy for maintenance as indicated by the high maintenance coefficient than those residual after either slime or LB-EPS extraction. In addition, the variation in bacteria community distribution across flocs was related to the variation in temperatures, suggesting that the inner part of a floc might be hotter than the outer side. Therefore, compared to bacteria in the raw sludge, the viable bacteria bounded in LB-EPS and TB-EPS convert more energy to heat rather than growth. These results indicate that energy was dispersed as metabolic heat for the LB-EPS extracted sludge, and removal of LB-EPS favored thermogenesis and sludge reduction. Based on the above findings, a simultaneously EPS-recovery and performance enhancement configuration is thus proposed, which holds great promise for the integration of next-generation wastewater treatment plants.
environmental sciences,engineering, environmental,water resources