Abstract:The effects of Ca(II), Mg(II), Cu(II), and Fe(III) on the flotation separation of spodumene from feldspar and quartz were investigated by single-mineral and artificial-mixed-ore flotation experiments using α-bromododecanoic acid (α-BDDA) as a collector. At pH≈7, Ca(II), Mg(II), and Cu(II) selectively improved the flotation of spodumene, which facilitated the separation of spodumene. Although Fe(III) exhibited strong activation ability, its selectivity toward spodumene was low, which impaired the separation of spodumene. Moreover, the sequence of addition of metal ions had an impact on the separation of spodumene. When Ca(II) and Mg(II) were used as activators in the artificial-mixed-ore flotation experiments, concentrates with recoveries of 75.6% and 76.3% and Li2O grades of 5.8% and 5.2% were obtained, respectively. Adsorption and activation mechanisms of metal ions were analyzed by adsorption amount measurements, Fourier transform infrared spectroscopy, species distribution calculation, and frontier orbital theory calculation. Results indicated that the amount of α-BDDA adsorbed on spodumene was higher than those adsorbed on feldspar and quartz when Ca(II), Mg(II), and Cu(II) were employed as activators, which led to a higher recovery of spodumene. When the pH was approximately 7, Ca(II), Mg(II), Fe(III), and Cu(II) were mainly present as Ca2+, Mg2+, Fe(OH)3 and Fe(OH)2+, and Cu(OH)2, Cu2+, and Cu(OH)+, respectively. The results of frontier orbital theory calculations demonstrated that α-BBBA, Ca2+, and Mg2+ easily adsorbed on spodumene than on feldspar and quartz. Therefore, Ca(II) and Mg(II) facilitated the separation of spodumene. However, Fe(OH)2+ preferentially reacted with spodumene, whereas Fe(OH)3 preferably reacted with feldspar and quartz, which caused low selectivity of Fe(III) toward spodumene. Similarly, Cu2+ and Cu(OH)+ easily adsorbed on spodumene, whereas Cu(OH)2 preferentially adsorbed on feldspar and quartz. Thus, the selectivity of Cu(II) toward spodumene was inferior compared to those of Ca(II) and Mg(II).

Effects of Ca<sup>2+</sup> and SO<sub>4</sub><sup>2−</sup> Ions on Fluorite Flotation

Effects of Pb2+ Ions on the Flotation Behavior of Scheelite, Calcite, and Fluorite in the Presence of Water Glass

Original Data and Descriptions from Inhibition Mechanism of Ca2+, Mg2+ and Fe3+ in Fine Cassiterite Flotation Using Octanohydroxamic Acid

Effect of Grinding Media on the Flotation Behavior of Fluorite Using Sodium Oleate As a Collector

Effect of Zn<SUP>2+</SUP> and its addition sequence on flotation separation of scheelite from calcite using water glass

Behavior of Lead Ions in Cassiterite Flotation Using Octanohydroxamic Acid

Effect of Ca(II) on anionic/cationic flotation of magnesite ore

Decoupling the effects of solid and liquid phases in a Pb-water glass mixture on the selective flotation separation of scheelite from calcite

Inhibition Mechanism of Ca2+, Mg2+ and Fe3+ in Fine Cassiterite Flotation Using Octanohydroxamic Acid

Effects of Alkyl Ether Amine and Calcium Ions on Fine Quartz Flotation and Its Guidance for Upgrading Vanadium from Stone Coal

The effect of calcium ions on the flotation behavior of fluorapatite

Effect of Ca2+ dissolution and migration transformation from phosphorite on the surface properties of dolomite

Comparison of Sodium Oleate and Sodium Petroleum Sulfonate for Low-Temperature Flotation of Fluorite and the Collecting Mechanisms

Enhanced Pyrophyllite Flotation Performance Using Sodium Oleate as an Anionic Collector in the Presence of Ammonium Ion

Slow-release of fluorite and its effect on flotation separation of magnesite from calcite

Adsorption of octanohydroxamic acid at fluorite surface in presence of calcite species

Insights into the influence of calcium ions on the adsorption behavior of sodium oleate and its response to flotation of quartz: FT-IR, XPS and AMF studies

Effect of sulfuric acid pretreatment on flotation performance of calcite and fluorite

Effects of metal ions on the flotation separation of spodumene from feldspar and quartz

Effects of Interfacial Hydroxylation Microstructure on Quartz Flotation by Sodium Oleate

Flotation behavior and mechanism of styrene phosphonic acid as collector on the flotation separation of fluorite from calcite

Effects of Ca&lt;sup&gt;2+&lt;/sup&gt; and SO&lt;sub&gt;4&lt;/sub&gt;&lt;sup&gt;2−&lt;/sup&gt; Ions on Fluorite Flotation