Synthesis of Aspartame with Lactone Method

Zhen Yu

2002-01-01

Abstract:Aspartame was synthesized from L aspartic acid by lactonization and using dehydro xymethylation and then deprotection method to avoid the by product of N methylaspartame, and so to improve the quality of the final end product.

What problem does this paper attempt to address?

Optimization for the Synthesis of Aspartame Intermediate

崔晓君,陈志荣,鲁波

DOI: https://doi.org/10.3321/j.issn:1003-5214.2002.07.019

2002-01-01

Abstract:The reaction conditions for synthesizing aspartame intermediate--N-ethoxythiocarbonylaspartic acid were optimized with the uniform design method.The optimized conditions were:reaction temperature 72 ℃,n(methylethylxanthate)∶n(aspartic acid)=1.50∶1.00,m(aspartic acid)∶m(sodium hydroxide)=0.50∶1.00,m(water)∶m(aspartic acid)=4.00∶1.00 and m(methanol)∶m(water)=0.15∶1.00.The yield of N-ethoxythiocarbonylaspartic acid was 88.92%.
Synthesis of High Potency Sweetener N-[3-(3-hydroxy-4-methoxyphenyl)propyl]-aspartyl-L-henylalaninel-methylester

Wu Meihong,Zheng Jianxian

2009-01-01

Abstract:The development of high potency sweetener changes rapidly,sweetener with safety,low cost,high degree of sweetness and top properties is the trend in food industry.On the basis of sweet mechanism,by the reaction of aspartame and 3-hydroxy-4-methoxyphenylpropylaldehyde under the catalysis Pd/C,a new sweetener N-[3-(3-hydroxy-4-methoxyphenyl)propyl]-aspartyl-L-henylalaninel-methylester is synthesized.Because of hydrophobic group added on aspartame derivative,the sweetness is 23 000 times higher than that of cane sugar.Furthermore,the method is simple and available with high yield.The paper summarizes the synthesis method of the important intermediate,3-hydroxy-4-methoxyphenylpropylaldehyde,with 49.8% yield,which makes the high potency sweetener possible.
THE REMOVAL PROPERTIES AND MECHANISMS OF L-PHENYLALANINE IN ASPARTAME CONDENSATION SOLUTION BY RESINS ADSORPTION METHOD

Huan QIU,Weili JIANG,Fuqiang LIU,Yanmeng GONG,Qi JIANG,Shuyang LIU,Wei ZHAO

DOI: https://doi.org/10.16026/j.cnki.iea.2018010049

2018-01-01

Abstract:The removal and separation properties of L-phenylalanine (L-Phe) in aspartame condensation solution from the adsorption resins XAD-300 and LS-106 were compared. Langmuir and Freundlich models both described the isotherm data well. The adsorption thermodynamics parameters indicated that the adsorption processes were both spontaneous and exothermic. The greater value of △HФ and △GФ of L-Phe onto XAD-300 indicated stronger adsorption affinity between them. The adsorption kinetics curves of L-Phe were fitted well by Pseudo-second-order kinetics and the initial adsorption rate of XAD-300 was higher than that of LS-106, which was related to the stronger adsorption affinity of L-Phe onto XAD-300. Dynamic adsorption results revealed that the breakthrough points of L-Phe onto XAD-300 and LS-106 were 44BV and 6BV, respectively, and the breakthrough adsorption amount of XAD-300 was 1.70mmol/g, about three times greater than that of LS-106. Finally, the loaded L-Phe onto XAD-300 was thoroughtly recycled by 0.lmmol/LNaOH and 99.6％ L-Phe could be recovered. The amount of aspartic acid had no effect on the adsorption of XAD-300, but the coexistence of sodium chloride slightly inhibited the adsorption of L-Phe. The stronger adsorption affinity of XAD-300 was mainly related to its abundant microporous structure, and the microporous filling may be the dominant mechanism.
One Step Synthesis of Inverted Aspartame Type Sweetener, Ac-Phe-Lys, Using Chemically Modified Chymotrypsin

J Oaki,K Nakahara,M Tamura,H Okai

DOI: https://doi.org/10.1271/bbb.63.1156

Abstract:To search for techniques of simplified peptide synthesis, benzyloxycarbonyl chymotrypsin was prepared by a water-soluble acylating reagent and used to make Ac-Phe-Lys, an artificial peptide sweetener, which was selected as a target compound. As a result of using chemically modified chymotrypsin, Lys can be coupled directly with Ac-Phe and Ac-Phe-Lys made virtually in one step. Moreover, the total yield from preparation and purification steps for Ac-Phe-Lys was 13%. The value corresponds to that of the chemical synthesis method. On the contrary, enzymatic synthesis using native chymotrypsin cannot reach the level of the new method. It is expected that the method is more effective for simplified peptide synthesis as compared with other methods, especially on a large scale.
Synthesis of Methoxy-Substituted Diazirinyl Phenylalanine – A Novel Photoreactive Aspartame Derivative for Functional Analysis of Sweet Receptors

Munenori Sakurai,Katsuyoshi Masuda,Lei Wang,Yuta Murai,Yasuko Sakihama,Yasuyuki Hashidoko,Yasumaru Hatanaka,Makoto Hashimoto

DOI: https://doi.org/10.3987/com-13-s(s)14

IF: 0.6

2014-01-01

Heterocycles

Abstract:Photoreactive phenylalanine derivatives are well known as functional analysis reagents for target biomolecules. The photophores are commonly introduced at 4-position on benzene. Aspartame, which consists of dipeptide L-Asp-L-Phe-OMe, is one of the most utilized artificial sweeteners, and substitution effects on its benzene ring have been reported. Substitution at the 4-position, however, does not maintain its sweetness properties. Trifluoromethyldiazirine, which is one of the most reliable photophores, was introduced to a different site on phenylalanine and the new photoreactive phenylalanine was converted to aspartame derivatives. The new aspartame derivative had slightly higher sweetness potency than sucrose standard solution.
Synthesis of ( S )-1-tert-butyl-2-( Tert-Butyloxycarbonylamino )-Aspartate Semi-Aldehyde

HONG Wei,WANG Hao

DOI: https://doi.org/10.3969/j.issn.0258-3283.2012.03.028

2012-01-01

Abstract:(S)-1-tert-Butyl-2-(tert-butyloxycarbonylamino)-aspartate semi-aldehyde was synthesized from L-aspartic acid by a five-step reaction in total yield of 25% and the structure was confirmed by specific rotation,1HNMR and 13CNMR.
Synthesis of peptides by reactive extrusion. Application to the continuous and solventless preparation of aspartame.

Frédéric Lamaty,Tharwat Mohy El-Dine,Matthieu Lavayssiere,Hélène Adihou,Gilles Subra,Thomas-Xavier Métro,Olivier Ludemann-Hombourger

DOI: https://doi.org/10.26434/chemrxiv-2023-2hhhk-v2

2024-03-01

Abstract:The solventless synthesis of peptides from unactivated amino acids was performed in a twin-screw extruder. The general method was applied to the preparation of dipeptides and tripeptides. Aspartame, a synthetic dipeptide, was also prepared in a continuous mode on large scale.

Chemistry
Isolation and Characterization of the Aspartame-Degrading Strain Pseudarthrobacter Sp. AS-1.

Zhijian Ke,Junyun Song,Jingrui Ma,Mengting Wang,Haiguang Mao,Chunli Xia,Lili Qi,Yidong Zhou,Jinbo Wang

DOI: https://doi.org/10.1016/j.envpol.2023.122883

IF: 8.9

2023-01-01

Environmental Pollution

Abstract:Aspartame is one of the main varieties of artificial sweeteners. Although it has been approved as a food additive, the environmental hazards and ecological risks posed by aspartame are attracting more and more attention. In the present study, strain Pseudarthrobacter sp. AS-1 was isolated and characterized as an efficient aspartame degrader. Strain AS-1 was capable of degrading 200 mg L-1 aspartame within 10 h under conditions optimized at 30 degrees C and pH 8.0. At the same time, it was found that enzymes degrading aspartame in strain AS-1 were induced and secreted extracellularly. Degradation of aspartame in Pseudarthrobacter sp. AS-1 was identified as following: it was first demethylated to aspartyl-phenylalanine, then degraded to phenylalanine and aspartate, and finally the two amino acids were further degraded. In addition, strain AS-1 was able to remove more than 85% of aspartame in soil and river water. It is the first time that pure bacterial cultures were reported to have the capability of aspartame degradation. These findings add to our knowledge of the microbial metabolic mechanisms of aspartame.
Study on the Preparation of a New Sweetener-Nc-asp

Tu JIANG,Jian-xian ZHEN,Yi-lu BAO

DOI: https://doi.org/10.13652/j.issn.1003-5788.2009.01.014

2009-01-01

Abstract:This research,based on the sweetness theory,through the reaction of P-Chlorobenzaldehyde and Aspartame under the catalysis by Pd/C,has developed a new dipeptide sweetener,N-[N-(4-Chlorobenzyl)-L-.alpha.-aspartyl]-L-henylalanine1-methylester (NC-Asp). The result shows the sweetness of this product is enhanced 1500 times stronger than that of the sucrose by adding hydrophobic group Cl to Aspartame.
Immobilized Thermolysin and Synthesis of Precursor of Aspartame.

Qi-Feng Zhou,Zhen Huang

DOI: https://doi.org/10.1002/chin.199317230

1993-01-01

ChemInform

Abstract:ChemInform is a weekly Abstracting Service, delivering concise information at a glance that was extracted from about 100 leading journals. To access a ChemInform Abstract of an article which was published elsewhere, please select a “Full Text” option. The original article is trackable via the “References” option.
Synthesis of a New Antihyperlipidaemic Agent-Simvastatin

LI Chuan-mao,HUANG Guo-lin,LIU Zhi-rong,KANG Wen,YU zhi-you

DOI: https://doi.org/10.3969/j.issn.1674-3504.2005.02.013

2005-01-01

Abstract:Simvastatin is a new antihyperlipidaemic agent. It can be synthesized with the material of lovastatin, hydroxy protecting agent of trimethylchlorosilane, and t-butyl lithium instead of pyrrole lithium. The total yield is about 78%.The structure is identified by UV,IR,MS,NMR spectrums.This method is very easy and the cost is very low, but the yield is high. Most of organic solvents can be recovered in order to be used next time. So this method will have perfect industrialization foreground.
Improved Method for Lacosamide Synthesis with Chemoenzymatic Method

Wang Zhi-yuan,Xu Li-sheng,Liu Jun-zhong,Zhang Hong-juan,Gao Ji,Liu Qian,Jiao Qing-cai

IF: 3.1

2012-01-01

Chemical Research in Chinese Universities

Abstract:Lacosamide was prepared by chemical method coupled with enzymatic method. N-Acetyl-D, L-3-methoxy-alanine, derived from D,L-3-methoxy-alanine, was used in the resolution process catalyzed by immobilized Escherichia coli cells with aminoacylase(EC3.5.1.14) activity. N-Acetyl-D-3-methoxy-alanine and L-3-methoxy-alanine were obtained from the resolution system. Lacosamide was synthesized by the amidation of N-acetyl-D-3-methoxy-alanine with benzylamine.
Determination of Aspartame by High Performance Liquid Chromatography in Health Foods and Drinks

YANG Liu-hua,Wang Lin,Sun Cheng-jun

DOI: https://doi.org/10.3969/j.issn.1000-0720.2007.07.021

2007-01-01

Abstract:A method for the determination of aspartame by high performance liqiud chromatography in health foods and soft drinks was reported in this paper.The solid sample is dissolved in water and then ultrasonically extracted.The drink samples were ultrasonically degased.After filtrated with 0.45 μm filtration membrane,20 μL of the filtrate was injected into high performance liquid chromatograph and separated with a C18 column(250×4.6 mm,10 μm).The chromatographic separation conditions were: column temperature was 35 ℃,the mobile phase was 10 mmol/L potassium dihydrogen phosphate(pH 3.50) and acetonitrile in the ratio of 80 to 20,with a flow rate of 1 mL/min.The detection wavelength was 210 nm.The linear range of the method was 0～16 μg with a detection limit of 0.0024 μg.The recoveries of the method were between 92.3% and 102%.The relative standard deviation of the method were less than 1.6%.The method is simple,time-saving,accurate and precise and it is applicable to the determination of aspartame in health foods and drinks.
A New Synthesis of Neu5Ac from D-Glucono-δ-lactone

KG Liu,S Yan,YL Wu,ZJ Yao

DOI: https://doi.org/10.1021/jo026056o

2002-01-01

The Journal of Organic Chemistry

Abstract:A new route to Neu5Ac methyl ester (23) with a readily available sugar D-glucono-delta-lactone as starting material has been developed. A diastereoselective propargylation of alpha-acetamino aldehyde and a subsequent KMnO(4) oxidation of the terminal alkyne served as the key steps.
Improvement of Synthetic Method of Lysine Aspirin

Kun Chen,Xin Zhu,Qikang Tian,Lan Zhang

DOI: https://doi.org/10.1088/1757-899x/677/2/022054

2019-12-01

IOP Conference Series: Materials Science and Engineering

Abstract:Abstract The synthesis method of lysine aspirin was improved, and the new method was applied to the synthesis of similar new drugs. Aspirin is reacted with an aqueous solution of sodium hydrogen carbonate to prepare its sodium salt, and lysine was reacted with a sodium salt thereof in water to prepare lysine aspirin. The product was identified by melting point, infrared spectroscopy and high performance liquid chromatography; the cysteine salts of aspirin was prepared by this method, and the product was identified by micro melting point apparatus and infrared spectroscopy. Lysine aspirin was synthesized by the reaction of sodium acetylsalicylate with lysine. The author measured the melting point and infrared absorption spectrum of the cysteine salt sample of aspirin, which was initially determined to be possible. The new method offers the possibility to expand the production route of lysine aspirin, and also provides new ideas for the preparation of similar new drugs.
Chemoenzymatic Synthesis of L-3,4-dimethoxyphenyl-alanine and Its Analogues Using Aspartate Aminotransferase As a Key Catalyst

Jinhai Yu,Jing Li,Shuangyan Cao,Ting Wu,Shuiyun Zeng,Hongjuan Zhang,Junzhong Liu,Qingcai Jiao

DOI: https://doi.org/10.1016/j.catcom.2018.10.033

IF: 3.51

2018-01-01

Catalysis Communications

Abstract:In this study, a chemoenzymatic synthesis method for the production of L-3,4-dimethoxyphenyl-alanine and its analogues from phenylpyruvate derivatives was developed. The aspartate aminotransferase from Escherichia coli was engineered by error prone PCR and the improved variants were identified. When 3, 4-dimethoxy phenylpyruvate was added by fed-batch on a preparative scale, L-3,4-dimethoxyphenyl-alanine was formed in 95.4% conversion and > 99% ee with the best aspartate aminotransferase variant as the catalyst. This study provided an efficient method for the production of methoxy substituted phenylalanines using the engineered aspartate aminotransferase.
A Novel and Formaldehyde-Free Preparation Method for Lignin Amine and Its Enhancement for Soy Protein Adhesive

Junna Xin,Pei Zhang,Michael P. Wolcott,Jinwen Zhang,William C. Hiscox,Xiao Zhang

DOI: https://doi.org/10.1007/s10924-016-0844-x

IF: 4.705

2016-01-01

Journal of Polymers and the Environment

Abstract:In this work, a novel two-step process to prepare primary lignin amine was developed. The lignin used in this study was obtained from the residue of cellulosic sugar fermentation for bioethanol (referred as “lignin”). The lignin was initially oxidized through Fenton oxidation. The oxidized lignin was further converted to lignin amine by reductive amination. Ammonia was used in the second step leading to give the highly active primary lignin amine. The oxidation and reduction exhibited relatively high yields of 80.0 and 91.2 % respectively. For comparison, lignin was partially depolymerized via mild hydrogenolysis and then the partial depolymerized lignin was also converted to lignin amine using the same method. The obtained lignin amines were characterized in detail using elemental analysis, proton nuclear magnetic resonance ( 1 H NMR), and Fourier transform infrared spectroscopy (FTIR). Further, modification of soy protein adhesive by lignin amine was exemplified in wood bonding, and the results indicated that addition of lignin amine greatly increased water resistance of soy protein adhesives.
Aspartame: A review of functional properties and physiology impacts of aspartame

Yuxin Zhang

DOI: https://doi.org/10.54254/2753-8818/45/20240521

2024-07-26

Abstract:Aspartame is a high-intensity, low-calorie, synthetic sweetener which has been approved as a food additive (specifically as a sweetener) in the European Union and several nations worldwide. Primarily, it is employed as a sweetening agent in carbonated beverages, confectionery products, and pharmaceutical preparations. Despite the extensive utilisation of this particular phenomenon, there continues to be ongoing debate over its safety. The Food and Drug Administration (FDA) acknowledges the findings of the International Agency for Research on Cancer (IARC) and the Joint FAO/WHO Expert Committee on Food Additives (JECFA) on aspartame, as stated on July 14, 2023. The classification of aspartame by the International Agency for Research on Cancer (IARC) as possibly carcinogenic to humans should not be interpreted as a direct causal relationship between aspartame use and cancer. This review paper presents a theoretical framework for the utilization of aspartame across several industries. It accomplishes this by examining its physical and chemical characteristics, physiological roles, contemporary approaches to chemical synthesis and biological production, as well as its application in the realm of food. The objective of this narrative inquiry is to enhance individuals comprehension regarding the utilization of aspartame and its potential impact on the human body through an examination of existing research. The present study examined a collection of scholarly papers pertaining to the impact of aspartame on many health aspects, including obesity, diabetes, pediatric and fetal health, phenylketonuria, and the potential carcinogenicity of this artificial sweetener. Further investigation is required in order to provide a comprehensive understanding of the potential impact of aspartame on human health.
Synthesis of Lauroyl Aldehyde Acetals of Ascorbic Acid

ZHANG Yi-wei,LIANG Guo-dong,LIN Dong-en

DOI: https://doi.org/10.3969/j.issn.1005-1511.2010.06.029

2010-01-01

Abstract:Lauroyl aldehyde acetals of ascorbic acid was synthesized using lauric acid as starting material by interesterification and Lewis acid rearrangement to the long-chains lauroyl acetaldehyde,and then react with ascorbic acid using p-TsOH as catalyst,DMSO as solvent.The structure was characterized by 1H NMR,IR and ESI-MS.

Synthesis of Aspartame with Lactone Method

Optimization for the Synthesis of Aspartame Intermediate

Synthesis of High Potency Sweetener N-[3-(3-hydroxy-4-methoxyphenyl)propyl]-aspartyl-L-henylalaninel-methylester

THE REMOVAL PROPERTIES AND MECHANISMS OF L-PHENYLALANINE IN ASPARTAME CONDENSATION SOLUTION BY RESINS ADSORPTION METHOD

One Step Synthesis of Inverted Aspartame Type Sweetener, Ac-Phe-Lys, Using Chemically Modified Chymotrypsin

Synthesis of Methoxy-Substituted Diazirinyl Phenylalanine – A Novel Photoreactive Aspartame Derivative for Functional Analysis of Sweet Receptors

Synthesis of ( S )-1-tert-butyl-2-( Tert-Butyloxycarbonylamino )-Aspartate Semi-Aldehyde

Synthesis of peptides by reactive extrusion. Application to the continuous and solventless preparation of aspartame.

Isolation and Characterization of the Aspartame-Degrading Strain Pseudarthrobacter Sp. AS-1.

Study on the Preparation of a New Sweetener-Nc-asp

Immobilized Thermolysin and Synthesis of Precursor of Aspartame.

Synthesis of a New Antihyperlipidaemic Agent-Simvastatin

Improved Method for Lacosamide Synthesis with Chemoenzymatic Method

Determination of Aspartame by High Performance Liquid Chromatography in Health Foods and Drinks

A New Synthesis of Neu5Ac from D-Glucono-δ-lactone

Improvement of Synthetic Method of Lysine Aspirin

Chemoenzymatic Synthesis of L-3,4-dimethoxyphenyl-alanine and Its Analogues Using Aspartate Aminotransferase As a Key Catalyst

A Novel and Formaldehyde-Free Preparation Method for Lignin Amine and Its Enhancement for Soy Protein Adhesive

Aspartame: A review of functional properties and physiology impacts of aspartame

Synthesis of Lauroyl Aldehyde Acetals of Ascorbic Acid