Abstract:ZrO2-Supported H3PW12O40 (HPW) catalysts were used to catalyze the dehydration of glycerol to produce acrolein at 315 degrees C under a high space velocity (GHSV(Glycerol) = 400 h(-1)). The catalysts were prepared by varying the loading of HPW on two ZrO(OH)(2) supports of different preparations, followed by calcination in flowing nitrogen. The use of alcogel-derived ZrO(OH)(2)-AN for the support, compared with conventional hydrogel-derived ZrO(OH)(2)-CP, produced HPW/ZrO2 catalysts that showed higher surface areas and better catalytic performance for the selective formation of acrolein from glycerol dehydration. Independent of the preparation history of ZrO2, the Keggin-anion density (HPW nm(-2)) at the catalyst surface appeared as a key to the selectivity and mass-specific activity of HPW for acrolein production. Acrolein selectivity as high as 70 mol% was obtained over the catalysts having the intermediate densities (0.18-0.65 HPW nm(-2)), at which most of the Keggin HPW remained intact after calcination up to 650 degrees C. At higher densities, destruction of the Keggin HPW would occur during the calcination, which led to lower acrolein selectivity. High selectivity (71 mol%) and high yield (>= 54%) for acrolein production were found sustainable over the best performing HPW/ZrO2-AN catalyst for reaction times up to 10 h. (C) 2008 Elsevier B.V. All rights reserved.

Catalytic Synthesis of Butyraldehyde 1,2-Propanediol Acetal with H_3PW_(12)O_(40)/PAn

Catalytic Dehydration of 2,3-Butanediol over P/Hzsm-5: Effect of Catalyst, Reaction Temperature and Reactant Configuration on Rearrangement Products

Studies on Synthesis of Cyclohexanone Diethyl Acetal

Acetalization of Carbonyl Compounds with 2,2,4-Trimethyl-1,3-pentanedio Catalyzed by Novel Carbon Based Solid Acid Catalyst

Synthesis of Perfume N-propyl Acetate by Catalysis of LaPW12O40

A Green and Sustainable Approach for Acetalization of Benzaldehyde Using Tungstophosphoric Acid Loaded on Metal Oxide Catalysts

Synthesis of Acetals or Ketals over Zeolite Hβ Catalyst

Microwave Enhanced Catalytic Hydration of Acrolein to 3-Hydroxypropionaldehyde Using Simultaneous Cooling: Experimental and Theoretical Studies

Synthesis of 1,3-Propanediol by Cross Aldol Reaction and Hydrogenation of Formaldehyde with Acetaldehyde

Synthesis of Acetals and Ketals Catalyzed by NaH2PO4

Palladium-Catalyzed Dehydrogenative Carbonylative Esterification of Allenoic Acids for the Synthesis of γ-Butyrolactone Derivatives

Selective direct oxidation of 1‐butanol into acetal using hydrogen peroxide and Cs5MPW11(H2O)O39 (M = Fe, Co, Cu) catalysts

Pd-H3PW12O40/Zr-MCM-41: An efficient catalyst for the sustainable dehydration of glycerol to acrolein

Methanesulfonic Acid As a More Efficient Catalyst for the Synthesis of Lauraldehyde Glycerol Acetal

Preparation of 1-Hydroxy-2,5-hexanedione from HMF by the Combination of Commercial Pd/C and Acetic Acid

Catalytic Synthesis of Acetals (Ketals) by HMCM-22 Zeolite

Transition Metal Acetylide Catalysts for Polymerization of Alkynes

Acidic catalysis of microporous polyoxometalate H3PW12O40/SiO2 in acetal reaction between benzaldehyde and ethylene glycol

Sustainable Production Of Acrolein: Preparation And Characterization Of Zirconia-Supported 12-Tungstophosphoric Acid Catalyst For Gas-Phase Dehydration Of Glycerol

Heteropolyacid (H 3 PW 12 O 40 ) supported MCM-41: An effective solid acid catalyst for the dehydration of glycerol to acrolein

Synthesis Of 3-Hydroxybutyraldehyde Over Highly Stable Solid Base Catalysts Prepared From Layered Double Hydroxides