Abstract:The metallurgical properties of blast furnace slag changed when high alumina iron ore was used extensively due to the resulting changes of the molten slag microstructure. In the study, based on typical CaO–MgO–SiO2–Al2O3 slag systems with different w(Al2O3) content, molecular dynamics simulation was used to calculate the microstructural properties of particles in the high-temperature slag system, such as bond length, partial radial distribution function, coordination numbers, and diffusion coefficient. In addition, X-ray diffraction (XRD), Fourier transform infrared (FTIR) spectroscopy, and 27Al solid-state magic angle spinning nuclear magnetic resonance (27Al SS MAS NMR) were used to detect and analyze the samples. The comprehensive calculations and experimental results show that increasing w(Al2O3) can enhance the structural stability of each ion pair, and the strength of the structural stability is such that Si–O > Al–O > Mg–O > Ca–O. The self-diffusion coefficients are as follows: Mg2+ > Ca2+ > Al3+ > Si4+, which leads to the transformation of the [SiO4]4−(Q0), [Si2O7]6−(Q1) and [Si2O6]4−(Q2) structural units to [Si2O5]2−(Q3). The degree of polymerization of slag increased as well as the stability of the structural units. Moreover, the coordination of Al will change from the [AlO6]9−octahedral structure of six-coordinated Al to the [AlO5]7−pentahedral structure of five-coordinated Al and the [AlO4]5−tetrahedral structure of four-coordinated Al. It was also found that the content of non-bridge oxygen in the whole slag system decreased continuously, leading to the increasing degree of polymerization of slag, and the experimental results were consistent with the molecular dynamics calculation.

Molecular Dynamics Study of the Structure of Calcium Aluminate Melts

Microstructural analysis by molecular dynamics simulation of aluminate ternary slag with alkaline oxide

Molecular Dynamics Simulations of the Structural Properties of Al2O3-based Binary Systems

Structural properties of molten silicates from ab initio molecular-dynamics simulations: comparison between CaO-Al$_2$O$_3$-SiO$_2$ and SiO$_2$

Effects of the amphoteric behavior of Al2O3 on the structure and properties of CaO–SiO2–Al2O3 melts by molecular dynamics

Gaining insights on high-temperature thermal conductivity and structure of oxide melts through experimental and molecular dynamics simulation study

Effects on structure of aluminosilicate glass with type of network modifier cations:ab-initio molecular dynamic simulations

Effect of Al2O3 on the Molten Slag Microstructure Information by Molecular Dynamics Simulation and Experimental Analysis

Effect of CaO Partial Substituted by BaO on Structure of Aluminotitanate Melts by Molecular Dynamics Simulation

Molecular Dynamics Simulation of the Structure and Properties for the CaO–SiO2 and CaO–Al2O3 Systems

Quantitative studies on the microstructure of ternary CaO–Al2O3–SiO2 glasses by Raman spectroscopy, 27Al MAS NMR and quantum chemistry ab initio calculation

The Effect of CaO(MgO) on the Structure and Properties of Aluminosilicate System by Molecular Dynamics Simulation

Ionic Self-Diffusion of Na2O–Al2O3–SiO2 Glasses from Molecular Dynamics Simulations

Polymeric Structure Evolution Behavior Analysis of Aluminosilicate-Based Smelting Slag

Molecular Dynamics Simulation on the Influence of Al2o3 on the Slag Structure at 1873 K

The structure of CaO–MgO–Al2O3–SiO2 melts and glasses doped with FeOX–NiO

Dynamics, Structure and Glass Formation of Calcium Aluminate Liquids

Influence of Al2O3 on the electrical conductivity and structure of calcium-silicate-based melts

Understanding the Relationship Between Structure and Thermophysical Properties of CaO-SiO 2 -Mgo-al 2 O 3 Molten Slags

In-Situ Studies of Structure Transformation and Al Coordination of KAl(MoO₄)₂ during Heating by High Temperature Raman and 27Al NMR Spectroscopies

Room temperature Raman spectroscopy and 29Si MAS NMR combined with high temperature Raman spectroscopy and DFT calculation of xMgO-(1-x)CaO–SiO2 glasses and melts