Synthesis of Butyl Lactate on Magnetic Solid Superacid Catalysts

Xiao Zhang

2003-01-01

Abstract:Magnetic solid superacid SO 2- 4/ZrO 2 was prepared by chemical modification of solid superacid. The yield of esterification achieved 96.5% with butyl alcohol. 0.3 mol, lactic acid 0.1 mol, magnetic solid superacid 1.2 g and reaction time 2.5 h. The catalyst could be isolated from other matters due to its magnetism, and the recycle percentage was 82.5%.

What problem does this paper attempt to address?

A Study on Synthesis of Esters by Superacid Resin Catalysts

HR YANG,BN LI,YX FANG

DOI: https://doi.org/10.1080/00397919408010250

1994-01-01

Synthetic Communications

Abstract:Superacid resin as catalyst, instead of the strong acid cation exchange resin and sulfuric acid was used to synthesis n-butyl lactate. Some factors affection reaction, such as time, moles ratio of reactants and catalyst amount were studied. Result made known that time was shorten very much. Under our optimum conditions the ester yield was over 99.5%. In the other hand, superacid resin as catalyst was used to synthesis other esters, had result of raise ester yield and shorten the time of esterification.
Preparation of Fibrous SO42-/ZrO2-Nio Solid Acid Catalyst, Characterization and its Catalytic Properties

qiang du,tian tian xu,x m song,ying zhang,yang liao,s l zhao

DOI: https://doi.org/10.4028/www.scientific.net/AMR.518-523.873

2012-01-01

Abstract:A novel SO42-/ZrO2-NiO solid acid catalyst was prepared by using collagen fiber as the template. It was found that the SO42-/ZrO2-NiO catalyst remained good fibrous morphology by scanning electron microscopy (SEM). The IR analysis suggested that the metal oxide surface and SO42- were combined to form dual-coordinate state. The catalyst had both medium strong acidic sites and strong acidic sites through temperature-programmed decomposition (TPD) of ammonia. The calcination temperature is inversely proportional to the surface area of fibrous ZrO2-NiO. The catalyst was applied to the esterification of acetic acid with n-butanol to estimate the catalytic activity and the best preparation conditions of SO42-/ZrO2-NiO solid acid catalyst was found out. The results showed the SO42-/ZrO2-NiO catalyst had high catalytic activity.
Preparation of Fibrous SO42-/ZrO2-Nio Solid Acid Catalyst, Characterization and Its Catalytic Properties

Qiang Du,Tian,Xue Mei Song,Ying Zhang,Yang Liao,Shi Lin Zhao

DOI: https://doi.org/10.4028/www.scientific.net/amr.518-523.873

2012-01-01

Advanced Materials Research

Abstract:A novel SO 4 2-/ ZrO 2 -NiO solid acid catalyst was prepared by using collagen fiber as the template. It was found that the SO 4 2-//sup>ZrO 2 -NiO catalyst remained good fibrous morphology by scanning electron microscopy (SEM). The IR analysis suggested that the metal oxide surface and SO 4 2- were combined to form dual-coordinate state. The catalyst had both medium strong acidic sites and strong acidic sites through temperature-programmed decomposition (TPD) of ammonia. The calcination temperature is inversely proportional to the surface area of fibrous ZrO 2 -NiO. The catalyst was applied to the esterification of acetic acid with n-butanol to estimate the catalytic activity and the best preparation conditions of SO 4 2-/ ZrO 2 -NiO solid acid catalyst was found out. The results showed the SO 4 2-/ ZrO 2 -NiO catalyst had high catalytic activity.
Synthesis of Benzocaine Catalyzed by Solid Superacid SO_4~(2-)/ZrO_2

Weihong Li

2010-01-01

Abstract:Objective:To establish a new method for benzocaine preparation.Methods:Synthesize benzocaine from p-amino benzoic acid and ethanol by esterification in the presence of the catalysis of solid superacid SO42-/ZrO2.Results:Benzocaine was obtained from p-amino benzoic acid and ethanol by esterification with solid superacid SO42-/ZrO2 catalyst.When the use level of catalyst was 6% of mass of p-amino benzoic acid,reaction time was 40 min,the ratio of acid quality and mellow volume was 2∶25,the yield of benzocaine reached 91.2%,and the activity and reusability of catalyst remained good.Conclusion:The method for the synthesis of benzocaine shows advantages of high yield,stable and quick reaction,little pollution,and easy separateness of catalyst.
Catalytic Synthesis of Ethyl Chloroacetate with Nanosized Rare Earth Composite Solid Superacid SO_4~(2-)/ZrO_2-La_2O_3

Deng Bin,Zhang Aihua,Xu Anwu

2008-01-01

Abstract:Ethyl chloroacetate was synthesized from chloroacetic acid and ethyl alcohol with nanosized rare earth composite solid superacid SO_4~(2-)/ZrO_2-La_2O_3 as catalyst.The effects of molar ratio of chloroacetic acid to ethyl alcohol,catalyst dosage,water-carrying agent(cyclohexane)dosage and reaction time on the yield of ester were discussed.Experimental results showed that nanosized rare earth composite solid superacid SO_4~(2-)/ ZrO_2-La_2O_3 was an excellent catalyst.The optimum reaction conditions were as follows:chloroacetic acid 0.1 mol,molar ratio of alcohol to acid 3.0:1,nanosized rare earth composite solid superacid SO_4~(2-)/ZrO_2- La_2O_3 1.0 g,cyclohexane as water-carrying agent 15mL,reaction time 2 hours.The esterification ratio was up to 94.3% under the above optimum conditions.
Hydrolysis of biomass by magnetic solid acid

DaMing Lai,Li Deng,QingXiang Guo,Yao Fu

DOI: https://doi.org/10.1039/c1ee01526e

IF: 32.5

2011-01-01

Energy & Environmental Science

Abstract:A magnetic solid acid with mesoporous structure was synthesised for biomass saccharification and levulinic acid production. The catalyst shows improved performance for the hydrolysis of beta-1,4-glucan and carbohydrate dehydration than a conventional solid acid. Moreover, the catalyst can be easily separated from the reaction residues with an external magnetic force.
Synthesis of a novel multi-SO 3 H functionalized strong Brønsted acidic ionic liquid and its catalytic activities for acetalization

Jing Zhang,ShaoHua Bao,JianGuo Yang

DOI: https://doi.org/10.1007/s11434-009-0437-3

2009-01-01

Chinese Science Bulletin

Abstract:The novel multi-SO 3 H functionalized strong Brønsted acidic ionic liquid has been prepared and its catalytic activities were investigated through the acetalization. The results showed that the novel catalyst was very efficient for the reaction with the average yield over 90% under solvent-free condition at room temperature. Operational simplicity, without need of any solvent, a small amount of usage, low cost of the catalyst used, high yields, applicability to large-scale reactions and reusability are the key features of this methodology. The novel catalyst also has great potential for the green process.
Catalytic Synthesis of Benzyl Acetate with Rare Earth Solid Super Acid SO_4~(2-)/ZrO_2-Nd_2O_3 by Microwave Induced

XU An-wu

2007-01-01

Abstract:Benzyl acetate was synthesized by the esterification of benzyl alcohol with acetic acid by using of a new type of rare-earth compound solid superacid SO_4~(2-)/ZrO_2-Nd_2O_3 as catalyst under microwave irradiation. Influence factors on the esterification yield were discussed.The results showed that SO_4~(2-)/ZrO_2-Nd_2O_3 had higher catalytic activity for the esterification reaction. The optimized reaction conditions were: while molar ratio of benzyl alcohol to acetic acid was 2.0 (when acetic acid was 0.2 mol ), the amount of rare earth solid superacids was 1.8 g, the amount of cyclohexane as the water taking reagent was 12 mL, the power of microwave was 550 W, radiation time was 25 min, the esterification rate was about 96.3 %. The catalyst could be easily recovered and reused, and had very good activity stability.
Production of Dibutyl Maleate with SO42-/Fe2O3 Solid Acid Catalyst

Jun Deng,Xuejun Zhu,Wei Zhao,Yi Zhang

DOI: https://doi.org/10.12783/dtetr/apetc2017/11417

2017-01-01

DEStech Transactions on Engineering and Technology Research

Abstract:This paper explores the impact of catalyst dosage, molar ratio of normal butanol to maleic anhydride, reaction temperature and reaction time, etc. on esterification rate in combination with the synthesis of dibutyl maleate with SO42-/Fe2O3 solid super acid catalyst prepared with ferrous sulfate, a by-product to produce titanium dioxide. It turned out that the preferable conditions for the synthesis of dibutyl maleate with SO42-/Fe2O3 solid super acid catalyst are as follows: catalyst dosage accounting for 2.0% of the amount of reactive material, molar ratio of alcohol to acid of 3.5:1, reaction temperature of 120°C and reaction time of 3h. Under the preferable conditions, the esterification rate of normal butanol to maleic anhydride can reach 90% in esterification reaction. The infrared spectroscopy shows that the synthetic dibutyl maleate conforms to the standard diagram.
Synthesis of Sec - Butyl Acetate by SnCl4/SiO2 Catalyst

陈平

DOI: https://doi.org/10.3969/j.issn.1004-0935.2004.06.004

2004-01-01

Abstract:SnCl 4/SiO 2 was applied as a new catalyst to the esterification of acetic acid and sec-butyl alcohol. It has high activity and excellent selectivity as well as no corrosion to the facilities. Various reaction parameters such as ratio of alcohol to acid, catalyst amount, reaction time and reaction temperature were carefully studied. The optimum reaction conditions were: molar ratio of acetic acid to sec-butyl alcohol 1.8∶1, amount of catalyst was 1.5 g, reaction time was 6 h, reaction temperature 150 ℃. The conversion of acetic acid reached 89.31 % and the selectivity of esterification was 100% under the optimum conditions.
Synthesis and Performance of Sulfated Mesoporous Zorcina Solid Superacid

Ding-feng JIN,Xin-qing WANG,Hong-xiao JIN,ZhaoYin HOU,Xiao-ming ZHENG,Hong-liang GE

DOI: https://doi.org/10.3969/j.issn.1001-4381.2008.10.056

2008-01-01

Abstract:As the activity of different acids for the condensation between toluene and formaldehyde depended on the proporation of its strong acid site, mesoporous zirconia supported sulfate acid was synthesized via the self-assembly method and characterized via XRD, N2-adsorption and HRTEM. The thermal stability of the prepared mesoporous zirconia supported sulfate acids were checked at different calcination temperature. It was found that the structure of mesoporous zirconia remained under 600°C, but damaged at higher temperature. NH3-TPD found that the catalyst calcined at 500°C has the highest acid amount and this catalyst showed the highest activity in the condensation between toluene and formaldehyde. The conversion of formaldehyde reached 45.7%.
Highly Stable, Active and Recyclable Solid Acid Catalyst Based on Polymer-Coated Magnetic Composite Particles

Jianxin Luo,Xucheng Zhang,Chunyan Zhang,Tao Wang,Xue Chen,Hongyu Chen,Steve King,Changchun Wang

DOI: https://doi.org/10.1016/j.cclet.2019.05.034

IF: 9.1

2019-01-01

Chinese Chemical Letters

Abstract:A facile approach has been adopted for coating cross-linked polystyrene (PS) shells on the surface of Fe3O4 magnetic clusters using reflux-precipitation polymerization (RPP). Treating the PS shell with chlorosulfonic acid yields magnetic composite particles with acid functionality. By adjusting the amount and proportion of monomers (styrene and divinylbenzene), the obtained magnetic composite particle solid acid (MPM-5S) exhibits a saturation magnetization value of 18 emu/g, a specific surface area of 243 m2/g and an acid density of 2.113 mmol/g. The MPM-5S magnetic solid acid catalyst was evaluated for esterification of oleic acid with methanol to prepare biodiesel. Under mild conditions, the conversion of oleic acid reached 91% , which was much higher than the catalytic activity of Amberlyst-15 and close to the catalytic activity of concentrated H2SO4. The solid acid catalyst can be recovered by magnetic separation and reused three times maintaining over 95% of its initial catalytic activity. Additionally, the solid acid can be used to catalyze the dehydration of fructose to 5-hydroxymethylfurfural.
Studies on n-butane isomerization reaction on solid oxide super acid Pt-SO4 2- /ZrO2-Al2O3 catalysts

Zhanlin Xu,Lina Zhao,Liang Wang,Yuling Zhang,YingLi Bi

2005-01-01

Abstract:The composite solid oxide super acid Pt-SO4 2- /ZrO2-Al2O3 catalyst was prepared, and its structure, surface properties and catalytic activities for n-butane isomerization reaction were investigated by XRD, XPS, SEM, FT-IR. The results showed that the optimum A12O3 loading in the catalyst made ZrO2 tetragonal phase stable, prevented the transformation of ZrO2 from tetragonal phase to monoclinic phase. Pt doping on SO 4 2- /ZrO2-Al2O3 improved the catalytic activities for n-butane isomerization reaction. When the content of Al was 1.5% in the catalyst, the yield of i-butane was 37%, and its selectivity reached 70% above.
Synthesis of Bibutyl Oxalate by Catalysis of Nanosized Rare Earth Composite Solid Superacid under Microwave Radiation

Deng Bin,Zhang Aihua,Xu Anwu

DOI: https://doi.org/10.3969/j.issn.1009-8348.2008.05.008

2008-01-01

Abstract:Bibutyl oxalate was synthesized with oxalic acid and butyl alcohol as raw materials and nanosized rare earth composite solid superacid SO_4~(2-)/ZrO_2-2%Nd_2O_3 as catalyzer under microwave radiation.The factors influencing the synthesis were discussed.The results by orthogonal experiments showed that nanosized rare earth composite solid superacid SO_4~(2-)/ZrO_2-2%Nd_2O_3 was an excellent catalyst for synthesizing bibutyl oxalate. When the dosage of oxalic acid was 0.1mol,molar ratio of butyl alcohol to oxalic acid was 3.0:1,the dosage of catalyst was equal to 1.6%(based on the total mass of feed stock),microwave power was 468W, microwave radiation time was 14 min,the esterification ratio was more than 97%.Moreover,the catalyst could be easily recovered and reused,and had characteristics of low cost,high catalytic efficiency,wide availability, easy operation,and environmental friendliness.
Preparation and Properties of Ultrafine SO42−/ZrO2 Superacid Catalysts

CX Miao,Z Gao

DOI: https://doi.org/10.1016/s0254-0584(97)80177-0

IF: 4.778

1997-01-01

Materials Chemistry and Physics

Abstract:Ultrafine SO42−/ZrO2 superacid catalysts were prepared in a two-step synthesis by impregnating ultrafine crystalline ZrO2 with sulfuric acid. Ultrafine crystalline zirconia was obtained by supercritical drying of an alcogel. The crystallization, crystal size, surface area, sulfur content, acid strength and catalytic activity for n-butane isomerization of sulfated amorphous and ultrafine crystalline zirconia were tested and compared. The catalyst prepared from ultrafine crystalline zirconia has smaller crystallite size, larger surface area, greater sulfur content and higher superacidity. Hence, it displays higher catalytic activity and stability for n-butane isomerization.
Preparation and properties of ultrafine SO4 2- /ZrO2 superacid catalysts

ChangXi Miao,Zi Gao

IF: 4.778

1997-01-01

Materials Chemistry and Physics

Abstract:Ultrafine SO4 2- /ZrO2 superacid catalysts were prepared in a two-step synthesis by impregnating ultrafine crystalline ZrO2 with sulfuric acid. Ultrafine crystalline zirconia was obtained by supercritical drying of an alcogel. The crystallization, crystal size, surface area, sulfur content, acid strength and catalytic activity for n-butane isomerization of sulfated amorphous and ultrafine crystalline zirconia were tested and compared. The catalyst prepared from ultrafine crystalline zirconia has smaller crystallite size, larger surface area, greater sulfur content and higher superacidity. Hence, it displays higher catalytic activity and stability for n-butane isomerization.
Synthesis of a Novel Carbon Based Strong Acid Catalyst Through Hydrothermal Carbonization

Xuezheng Liang,Jianguo Yang

DOI: https://doi.org/10.1007/s10562-009-0109-6

IF: 2.936

2009-01-01

Catalysis Letters

Abstract:A novel carbon based strong acid catalyst has been synthesized through the sulfonation of the carbon materials from glucose. The novel acid catalyst was obtained through the hydrothermal carbonization instead of the traditional heat treatment, which made the carbonization process under much milder condition with higher yield. The novel heterogeneous catalyst owned the advantages of high acidity as much as 2.0 mmol/g, much higher than that of Nafion and Amberlyst-15 (0.8 mmol/g). The catalytic activities of the catalyst were investigated through the acetalization. The results showed that the novel catalyst was very efficient for the reaction. The novel carbon based acid catalyst holds great potential in the green chemical process.
A Novel Way To Prepare Gamma-Al2o3 Supported So42-/Zro2 Solid Superacid Catalysts For N-Butane Isomerization

T Lei,Y Tang,Wm Hua,Js Xu,Z Gao

IF: 9.1

2000-01-01

Chinese Chemical Letters

Abstract:Highly active solid superacid catalysts for n-butane isomerization, SZ/Al2O3-P, were prepared by supporting SO42-/ZrO2 (SZ) on gamma-Al2O3 carrier using a precipitation method. The activities of some catalysts were enhanced significantly. The activity of the most active sample, 60%SZ/Al2O3-P, was even about 2 times more active than that of the SZ catalyst.
Esterification And Transesterification On Al2o3-Doped Sulfated Tin Oxide Solid Acid Catalysts

Zhai De-Wei,Yue Ying-Hong,Hua Wei-Ming,Gao Zi

DOI: https://doi.org/10.3866/PKU.WHXB20100709

2010-01-01

Acta Physico-Chimica Sinica

Abstract:A series of Al2O3-doped (0.5%-3.0%, molar fraction) sulfated tin oxide catalysts were prepared by a co-precipitation method. The structures and textural properties of these catalysts were characterized by N-2 adsorption, thermogravimetric (TG) analysis, X-ray diffraction (XRD), X-ray photoelectron spectroscopy (XPS), diffuse reflectance infrared Fourier transform spectroscopy (DRIFTS), Raman spectroscopy, and Al-27 magic. angle spinning nuclear magnetic resonance (MAS NMR). The number of acid sites on the catalysts was measured by the potentiometric titration of n-butylamine. Their catalytic performance for the esterification of lauric acid with methanol and the transesterification of triacetin with methanol was also investigated. The results showed that the addition of Al2O3 to sulfated tin oxide improved the catalytic activity markedly. The remarkable activities of the Al2O3-doped catalysts are caused by the larger number of acid sites. The SO42-/SnO2 catalyst doped with a 1.0% molar fraction of Al2O3 exhibited the highest activity. The lauric acid conversion was 92.7% after esterification for 6 h, and the triacetin conversion was 91.1% after transesterification for 8 h on this catalyst.
A Novel Way to Prepare γ-Al2O3 Supported SO4 2-/ZrO2 Solid Superacid Catalysts for n-Butane Isomerization

Ting Lei,Yi Tang,Weiming Hua,Jinsuo Xu,Zi Gao

IF: 9.1

2000-01-01

Chinese Chemical Letters

Abstract:Highly active solid superacid catalysts for n-butane isomerization, SZ/Al2O3-P, were prepared by supporting SO4 2-/ZrO2 (SZ) on γ-Al2O3 carrier using a precipitation method. The activities of some catalysts were enhanced significantly. The activity of the most active sample, 60%SZ/Al2O3-P, was even about 2 times more active than that of the SZ catalyst.

Synthesis of Butyl Lactate on Magnetic Solid Superacid Catalysts

A Study on Synthesis of Esters by Superacid Resin Catalysts

Preparation of Fibrous SO42-/ZrO2-Nio Solid Acid Catalyst, Characterization and its Catalytic Properties

Preparation of Fibrous SO&lt;sub&gt;4&lt;/sub&gt;&lt;sup&gt;2-&lt;/sup&gt;/ZrO&lt;sub&gt;2&lt;/sub&gt;-Nio Solid Acid Catalyst, Characterization and Its Catalytic Properties

Synthesis of Benzocaine Catalyzed by Solid Superacid SO_4~(2-)/ZrO_2

Catalytic Synthesis of Ethyl Chloroacetate with Nanosized Rare Earth Composite Solid Superacid SO_4~(2-)/ZrO_2-La_2O_3

Hydrolysis of biomass by magnetic solid acid

Synthesis of a novel multi-SO 3 H functionalized strong Brønsted acidic ionic liquid and its catalytic activities for acetalization

Catalytic Synthesis of Benzyl Acetate with Rare Earth Solid Super Acid SO_4~(2-)/ZrO_2-Nd_2O_3 by Microwave Induced

Production of Dibutyl Maleate with SO42-/Fe2O3 Solid Acid Catalyst

Synthesis of Sec - Butyl Acetate by SnCl4/SiO2 Catalyst

Synthesis and Performance of Sulfated Mesoporous Zorcina Solid Superacid

Highly Stable, Active and Recyclable Solid Acid Catalyst Based on Polymer-Coated Magnetic Composite Particles

Studies on n-butane isomerization reaction on solid oxide super acid Pt-SO4 2- /ZrO2-Al2O3 catalysts

Synthesis of Bibutyl Oxalate by Catalysis of Nanosized Rare Earth Composite Solid Superacid under Microwave Radiation

Preparation and Properties of Ultrafine SO42−/ZrO2 Superacid Catalysts

Preparation and properties of ultrafine SO4 2- /ZrO2 superacid catalysts

Synthesis of a Novel Carbon Based Strong Acid Catalyst Through Hydrothermal Carbonization

A Novel Way To Prepare Gamma-Al2o3 Supported So42-/Zro2 Solid Superacid Catalysts For N-Butane Isomerization

Esterification And Transesterification On Al2o3-Doped Sulfated Tin Oxide Solid Acid Catalysts

A Novel Way to Prepare γ-Al2O3 Supported SO4 2-/ZrO2 Solid Superacid Catalysts for n-Butane Isomerization

Preparation of Fibrous SO<sub>4</sub><sup>2-</sup>/ZrO<sub>2</sub>-Nio Solid Acid Catalyst, Characterization and Its Catalytic Properties