Abstract:Hot air drying (HAD) is the most commonly used method for citrus peel drying. However, the long time and low efficiency of this process leads to the degradation of product quality and a reduction in antioxidant activity. Therefore, in this study, to improve the drying efficiency and increase the product quality of dried citrus peel, the effects of microwave vacuum drying (MVD) were compared with HAD and vacuum freeze drying (VFD) with respect to their drying kinetics, bioactive compound profile and antioxidant capacity. The results showed that the drying rate decreased with increasing sample load but increased with increasing microwave power. The Page model was the best model for fitting the drying curve of citrus peel during MVD, and the highest rehydration rate (84.5%) was obtained at a microwave vacuum power of 600 W. The microstructure of citrus peel dried by MVD was assessed by scanning electron microscopy, and a loose structure with highly porous material was observed, whereas citrus peel dried by HAD was compact. The total phenolic content (10.48 ± 0.21 mg GAE/g DW), total flavonoid content (6.54 ± 0.41 mg RE/g DW) and oxygen radical absorbance capacity (279.29 ± 11.37 µmol TE/g DW) values obtained for citrus peel dried via MVD were significantly higher than those obtained using HAD (p < 0.05). Several phenolic acid substances and flavonoid profiles were identified and quantified by HPLC-DAD, including coumaric acid, nobiletin, and tangeretin. The nobiletin content observed after MVD was significantly higher than that measured after HAD and VFD. The overall results of this study revealed that MVD at lower microwave powers appears to be a good alternative to the conventional HAD of citrus peel.

Effects of Four Drying Methods on the Quality, Antioxidant Activity and Anthocyanin Components of Blueberry Pomace

Effect of Different Drying Techniques on the Bioactive Compounds, Antioxidant Ability, Sensory and Volatile Flavor Compounds of Mulberry

Pulsed vacuum drying enhances drying of blueberry by altering micro-, ultrastructure and water status and distribution

Effects of different drying techniques on sea buckthorn pomace: comprehensive assessment of drying characteristics, physicochemical properties, and odor

Comparison of different drying methods on the physical properties, bioactive compounds and antioxidant activity of raspberry powders

Influence of Different Drying Techniques on the Drying Kinetics, Total Bioactive Compounds, Anthocyanin Profile, Color, and Microstructural Properties of Blueberry Fruit

Effect of different drying methods on aroma composition of blueberry powder

Comparison of Different Drying Technologies for Kiwifruit Pomace: Changes in Physical Characteristics, Nutritional Properties and Antioxidant Capacities

Combined Hot Air and Microwave-Vacuum Drying of Cranberries: Effects of Pretreatments and Pulsed Vacuum Osmotic Dehydration on Drying Kinetics and Physicochemical Properties

Effect of vacuum freeze drying and hot air drying on dried mulberry fruit quality

Improvement of drying efficiency and quality attributes of blueberries using innovative far-infrared radiation heating assisted pulsed vacuum drying (FIR-PVD)

Effect of drying and grinding on the contents of polyphenolics and anthocyanins in bayberry pomace

Drying sea buckthorn berries (Hippophae rhamnoides L.): Effects of different drying methods on drying kinetics, physicochemical properties, and microstructure

Production of Blueberry Pulp Powder by Microwave-Assisted Foam-Mat Drying: Effects of Formulations of Foaming Agents on Drying Characteristics and Physicochemical Properties

Comparison of different drying technologies for brocade orange (Citrus sinensis) peels: Changes in color, phytochemical profile, volatile, and biological availability and activity of bioactive compounds

The effect of microwave vacuum drying process on citrus: drying kinetics, physicochemical composition and antioxidant activity of dried citrus (Citrus reticulata Blanco) peel

Effects of Different Drying Methods on Drying Characteristics, Microstructure, Quality, and Energy Consumption of Apricot Slices

Influence of Different Drying Methods on the Browning, Phytochemical Components and Antioxidant Capacity of Choerospondias Axillaris Fruits

Effect of Freeze-Thaw Cycles on Juice Properties, Volatile Compounds and Hot-Air Drying Kinetics of Blueberry

Effects of Traditional and Advanced Drying Techniques on the Physicochemical Properties of Lycium Barbarum L. Polysaccharides and the Formation of Maillard Reaction Products in Its Dried Berries.

Influence of Different Drying Techniques on Phenolic Compounds, Antioxidant Capacity and Colour of Ziziphus jujube Mill. Fruits