Abstract:Nonlinear drag force has been a research frontier in complex gas-solid systems. The literature has reported that the commonly-used drag correlations often overestimate drag force and, thus, cause unrealistic homogeneous flow structures in gas-solid fluidized beds of fine particles. For solving this problem, the structure-dependent drag model, derived from energy-minimization multi-scale approach, is used in discrete simulations of fluid catalytic cracking particles in a small riser. The gas phase is dealt with by computational fluid dynamics. Particles are considered as a discrete phase and described by Newton’s second law of motion. Gas-particle phases are coupled according to Newton’s third law of motion. Simulations show that use of structure-dependent drag model results in drag reduction, the effect of which is not so apparent as that in simulations of the two fluid model. The particle clustering tendency, however, is more distinct and leads to more heterogeneous flow structures in riser flow with a much greater amplitude of outlet solid flux fluctuations. Moreover, the behaviors of particle and gas back-mixing can be captured in the present simulations, which was supported by past simulations and experimental data. The simulation time resolution is discussed. The spring constant can be artificially brought down for safe setting of larger time step when modelling the collision process between fine particles with a higher calculation load. To appropriately mimic the continuous decay of van der Waals force may, however, need a much smaller time step. There is also an obvious effect of space resolution on simulations. When using a grid size smaller than 3 times the particle diameter, the simulated clusters turn extraordinarily large, and the effect of gas-solid back-mixing turns insignificant.

A New Drag Model of Chain-Like Agglomerates in Stokes Region

Evolution and Fluidization Behaviors of Wet Agglomerates Based on Formation-Fragmentation Competition Mechanism

Modeling total drag force exerted on particles in dense swarm from experimental measurements using an inline image-based method

Models of Interphase Drag Force from Direct Numerical Simulations of Upward Turbulent Particle-Laden Channel Flows

Drag Model from Interface-Resolved Simulations of Particle Sedimentation in a Periodic Domain and Vertical Turbulent Channel Flows

A drag force formula for heterogeneous granular flow systems based on finite average statistical method

A Linkage Between Particle- and Cell-scale Drag Correlations for Packed Beds of Multi-sized Particles

Two-Way Coupling Model for Fractal-Like Agglomerate-Laden Multiphase Flow

Improved Drag Force Model and Its Application in Simulating Nanofluid Flow

A Drag Model Considering the Particle Size Distribution Via Multi-Subgrid for the Simulation of Downer

Microscale drag model considering the effect of interface between dense and dilute phases for gas-solid suspensions at moderate Reynolds numbers

Drag Force Model Corrections Based on Nonuniform Particle Distributions in Multi-Particle Systems

A General Solution of the Drag Force in Packed Beds of Multi-Sized Particles under Creeping Fluid Flow Conditions

Homogeneous drag models in gas–solid fluidization: Big data analytics and conventional correlation

Structure-dependent Drag in Gas–solid Flows Studied with Direct Numerical Simulation

Modelling of filtered drag force for clustered particle-laden flows based on interface-resolved simulation data

DPM Simulations of A-Type FCC Particles’ Fast Fluidization by Use of Structure-Dependent Nonlinear Drag Force

Neural-network-based drag force model for polydisperse assemblies of irregular-shaped particles

A cluster-based drag model of rough sphere for the simulation of fast fluidization

Modeling of the Drag Force in Polydisperse Gas-Solid Flow Via an Efficient Supervised Machine Learning Approach

An Effective Three-Marker Drag Model Via Sub-Grid Modeling for Turbulent Fluidization