Abstract:To improve the ejector refrigeration cycle performance, this paper presents a theoretical thermodynamic analysis of a novel two-stage ejector refrigeration cycle (TSERC) with a gas-liquid separator using R134a/R32 and R600a/R290 as refrigerant. By separating the relatively low-boiling-point and high-boiling-point refrigerants, the cycle compression ratio decreases, the cycle performance increases, and the energy utilization efficiency can be improved. Energy and exergy analysis were conducted for the traditional single-stage ejector refrigeration cycle (SSERC) and TSERC. The effect of the mixture mass fraction on cycle performance under a fixed external heat source operating condition was studied, and the cycle performance comparisons between TSERC and SSERC at different evaporation temperature, condensation temperature and generation temperature were conducted. Results show that for TSERC, the maximum COP values 0.126 and 0.11, the maximum exergy efficiency 4.51 % and 4 % are obtained as the low-boiling-point mass fraction equals 0.6 and 0.4 respectively for R134a/R32 and R600a/R290. It is found that exergy destruction mainly occurs in the low-pressure sub-cycle of TSERC, the top three largest exergy destruction components are ejector 1, condenser 1 and generator 1, while the smallest exergy destruction occurs in pump 2. In addition, cycle performance comparison between SSERC and TSERC shows that the maximum COP improvement increased by 41.6 % and 89.6 % for 134a/R32 and R600a/R290 for TSERC, while the maximum entrainment ratio improvement increased by 32.4 % and 87.6 %. Moreover, it is concluded that the cycle performance improvement of TSERC is more significant at lower evaporation temperature, higher condensation temperature, and lower generation temperature compared to SSERC.

Thermodynamic and Economic Analysis of Refrigerant Mixture R290/ R1234ze Used in an ORC-EERC System for Low Temperature Heat Sources

Performance Evaluation of an Ejector Subcooling Refrigeration Cycle with Zeotropic Mixture R290/R170 for Low-Temperature Freezer Applications

Theoretical Investigation on the Performance of a Modified Refrigeration Cycle Using Binary Zeotropic Hydrocarbon Mixture R170/R290

Theoretical Study of A Transcritical Ejector Refrigeration Cycle with Refrigerant R143a

Theoretical investigation on an ejector–expansion refrigeration cycle using zeotropic mixture R290/R600a for applications in domestic refrigerator/freezers

Performance Analysis of an Advanced Ejector-Expansion Autocascade Refrigeration Cycle

Performance Analysis of a Modified Zeotropic Mixture (R290/R600) Refrigeration Cycle with Internal Subcooler for Freezer Applications

Investigation on cascading cogeneration system of ORC (Organic Rankine Cycle) and CaCl2/BaCl2 two-stage adsorption freezer

Theoretical Analysis of a Double Ejector-Expansion Autocascade Refrigeration Cycle Using Hydrocarbon Mixture R290/R170

Performance Study of an Enhanced Ejector Refrigeration Cycle with Flash Tank Economizer for Low-Grade Heat Utilization

Energy and exergy analysis of zeotropic mixture R290/R600a vapor-compression refrigeration cycle with separation condensation

Performance evaluation on an internal auto-cascade refrigeration cycle with mixture refrigerant R290/R600a

Performance Evaluation of a Modified Refrigeration Cycle with Parallel Compression for Refrigerator-Freezer Applications

Theoretical Investigation and Comparative Analysis of the Linde–Hampson Refrigeration System Using Eco-Friendly Zeotropic Refrigerants Based on R744/R1234ze(Z) for Freezing Process Applications

Thermodynamic performance analyses and optimization of subcritical and transcritical organic Rankine cycles using R1234ze(E) for 100–200 °C heat sources

Experimental and simulation study on a zeotropic ORC system using R1234ze(E)/R245fa as working fluid

Thermodynamic analysis and parametric optimization of ejector heat pump integrated with organic Rankine cycle combined cooling, heating and power system using zeotropic mixtures

Energy and Exergy Analysis of a Novel Two-Stage Ejector Refrigeration Cycle Using Binary Zeotropic Mixtures{fr}analyse De L’énergie Et De L'exergie D'un Nouveau Cycle De Réfrigération À Éjecteur À Deux Étages Utilisant Des Mélanges Zéotropes Binaires

Energy, Exergy, and Economic (3E) Analysis of Transcritical Carbon Dioxide Refrigeration System Based on ORC System

Energetic and Exergetic Investigation of an Organic Rankine Cycle at Different Heat Source Temperatures

Thermodynamic performance analysis a power and cooling generation system based on geothermal flash, organic Rankine cycles, and ejector refrigeration cycle; application of zeotropic mixtures