Abstract:Zero-carbon fuels (H-2/NH3) replacing coal co-firing is a promising way to address carbon emissions. Hydrogen co-firing helps improve combustion stability at low loads and control pollutant emissions. This study used a safer water electrolysis gas (HHO) for the multi-coal co-firing adaptability test. The effects of HHO injection mode and flow rate on combustion intensity, flue gas emissions, and fly ash characteristics were investigated. The results showed that HHO and lean coal/lignite co-firing could significantly increase the combustion temperature. The maximum temperature increases after co-firing were 108 degrees C and 95 degrees C. As the HHO increased, the CO2 in lignite co-firing increased, and CO and unburnt carbon decreased, while the opposite results were observed for lean coal (LC). At the 2200L/h HHO co-firing, CO2 decreases by 14.46 % and 27.22 % for LC premixed co-firing (PC) and staged co-firing (SC). Compared to SC, PC is more conducive to promoting the complete combustion of coke. The NOX emissions of HHO/LC co-firing are lower than those of pure coal, reaching the lowest value of similar to 9 ppm under SC. As the HHO increases, the NOX of Lignite-PC first increases and then slowly decreases, while Lignite-SC has the opposite effect. Although various NOX emission trends are observed under different conditions, the results are dominated by a common mechanism - the competition between NOX reduction caused by HHO gas and the increase in co-firing temperature on NOX generation. The NOX of SC is all lower than that of PC. The SO2 emission from the LC co-firing decreases with the increase of HHO, while the SO2 from lignite increases. The SO2 of LC-SC can be reduced from similar to 142 ppm to 0 ppm. HHO gas injection inhibits the release and oxidation of sulfur in lean coal. The differences in coal types lead to different changes in SO2 of co-firing. HHO gas reduced the SO3 content of lignite fly ash by 38.01 %. The high-temperature reduction atmosphere promotes the decomposition of sulfates and increases SO2 emissions. HHO co-firing refines the particle size of fly ash. The ultra-fine and micron particle matter (PM) increases, and the content of PM>100 mu m in Lignite-SC decreased by 10.32 %.

Effects of Hydrogen Fraction in Co-Injection Gas on Combustion Characteristics of the Raceway in Low Carbon Emission Blast Furnace

Numerical Simulation Study of Co-injection of Pulverized Coal and Hydrogen in the Tuyere-Raceway

Numerical investigation of hydrogen-rich gas and pulverized coal injection in the raceway of a blast furnace with lower carbon emissions

CFD Study of Hydrogen Injection in Blast Furnaces: Tuyere Co-injection of Hydrogen and Coal

Co-injection of hydrogen and biochar (CoHB) in a simulated blast furnace: A univariate and multivariate study

Numerical Study of Hydrogen-Rich Fuel Coherent Jet in Blast Furnace Tuyere

Effects of Surrounding Hydrogen Injection Parameters on Coherent Jet Characteristics in Electric Arc Furnace Steelmaking Process

A Numerical Study of Scenarios for the Substitution of Pulverized Coal Injection by Blast Furnace Gas Enriched by Hydrogen and Oxygen Aiming at a Reduction in CO2 Emissions in the Blast Furnace Process

Effect of H2 on Blast Furnace Ironmaking: A Review

Numerical Investigation of Burden Distribution in Hydrogen Blast Furnace

Blast furnace hydrogen-rich metallurgy-research on efficiency injection of natural gas and pulverized coal

Numerical study of natural gas and pulverized coal co-injection into an ironmaking blast furnace

Comparative Experimental Study on the Co-Firing Characteristics of Water Electrolysis Gas (HHO) and Lean Coal/lignite with Different Injection Modes in a One-Dimensional Furnace

Numerical investigation of the impact of injecting coke oven gas on raceway evolution in an ironmaking blast furnace

Computational Study of Hot Gas Injection (HGI) into an Ironmaking Blast Furnace (BF)

Effect of Mixed Charging of Nut Coke and Sinter on Hydrogen-Rich Smelting Process of Blast Furnace

Combustion behavior of co-injecting flux, pulverized coal, and natural gas in blast furnace and its influence on blast furnace smelting

Experimental Study on the Effects of Co-Firing Mode and Air Staging on the Ultra-Low Load Combustion Assisted by Water Electrolysis Gas (HHO) in a Pulverized Coal Furnace

Mathematical simulation and experimental study on coke oven gas injection aimed to low carbon blast furnace ironmaking

Effects of Hydrogen-Enriched Reduction on Metallurgical Properties of Iron-Bearing Burdens Under BF Operation with COG Injection

Theoretical insight into the competitive effect of CO2 and additive H2O in coke gasification