Abstract:Exploration of efficient deep red phosphor based on non-rare-earth ion activated oxide is of great practical value in the field of phosphors converted white light-emitting diode lighting. A spinel Mg1+yAl2-xO4:xMn(4+), yMg(2+) phosphor with deep red emission is synthesized by a solid-state reaction route. The crystal structure and morphology are characterized by powder X-ray diffraction and scanning electron microscopy. The luminescent performance is characterized by fluorescence spectrophotometer and fluorescence decay curves. The results demonstrate that the synthesized phosphor shows that two excited spectrum bands centered at 290 nm and 438 nm cover a broad spectral region from 220 nm to 500 nm due to the Mn4+-O2- charge transfer band and the (4)A(2)-T-4(1) and T-4(2) transitions of Mn4+ ions. Upon excitation at 300 nm, a strong, narrow red emission band is observed between 600 and 700 nm peaked at 652 nm as a result of the spin-forbidden E-2(g)-(4)A(2g) electron transition of Mn4+. The corresponding chromaticity coordinate is (0.7256, 0.2854). Additionally, the concentration quenching of Mn4+ in the MgAl2O4 host is evaluated in detail, which indicates that the optimum doping concentration of Mn4+ is experimentally determined to be 0.14 mol%. The critical distance is calculated to be 52.15 angstrom according to the Blasse equation, which elucidates that the concentration quenching mechanism is consequently very likely to be induced by the multipole-multipole interaction. The crystal field strength (D-q) and the Racah parameters (B and C) are estimated to evaluate the nephelauxetic effect of Mn4+ suffered in MgAl2O4:Mn4+ host lattice. Luminous mechanism is explained by Tanabe-Sugano energy level diagram of Mn4+ ion. The ratio of Dq/B equals 1.74, indicating that Mn4+ ions experience a weak crystal field in the MgAl2O4 host and emission peak energy of E-2(g)-(4)A(2g) transition is dependent on the nephelauxetic effect. The red emission intensity of Mg1+yAl2-xO4:xMn(4+), yMg(2+) increases on account of excess Mg2+ which would compensate for the local charge balance surrounding Mn4+ ions, furthermore, lead the Mn4+-Mn4+ pairs connected with interstitial O2- to transform into isolated Mn4+ ions, and thus eliminating energy transfer and enhancing the luminescence efficiency effectively. The decay times of two time-dependent curves of Mg1+yAl2-xO4:xMn(4+), yMg(2+) are 0.672 ms and 0.604 ms, and each entire decay curve could be well-fitted to single-exponential, confirming that there is only a single Mn4+ ion luminescence center. The decay time of Mn 4 + luminescence is prolonged with the increase of Mg2+ content, indicating that excitation energy transfer and non-radiative relaxation between Mn4+-Mn4+ pairs decrease, the reason is that photoexcitation energy can be temporarily stored in the trapping centers induced by excess positive charges. These results imply that Mn4+ doped Mg1+yAl2-xO4:xMn(4+), yMg(2+) is a promising candidate of deep-red phosphors for near-UV and blue light emitting diodes. These findings in the paper would be beneficial not only to developing a low-cost and safe strategy to produce high-efficient Mn4+ activated luminescent materials for white light emitting diodes, but also to providing a new insight into improving the photoluminescence properties of Mn4+.

MgAl2O4:Mn2+ Red-Emitting Phosphor: Influence of MgF2 Flux on the Microstructure and Luminescence Properties

Synthesis, Structure and Luminescence Properties of Mn-doped MgAl2O4 Red-Emitting Phosphors with Varying Sintering Temperature

Preparation of Mg1+yAl2-xO4:xMn(4+), yMg(2+) deep red phosphor and their optical properties

Insight into a Novel Rare-Earth-free Red-Emitting Phosphor Li3Mg2NbO6:Mn4+: Structure and Luminescence Properties

Luminescent properties of SrMgAl10 O17∶Eu2+,Mn2+ high-efficiency phosphor prepared via the sol-gel combustion method

Monodisperse Micro-Spherical Sr2–Mg1+Y Al22–O36:xMn4+ Red Phosphors

Site Occupancy Preference, Enhancement Mechanism, and Thermal Resistance of Mn4+ Red Luminescence in Sr4al14o25: Mn4+ for Warm Wleds

Red-Emitting Aln:Mn2+ Phosphors Prepared By Combustion Synthesis

Crystal Structure and Luminescence Mechanism of Novel Fe3+ Doped Mg0.752Al2.165O4 Deep Red‐emitting Phosphors

Optical Characteristics, Morphology Evolution and Thermal Stability of Novel Red-Emitting Mn4+-activated K2LiAl1-yGayF6 Solid Solution Phosphors for High-Performance Warm WLED

Luminescence properties, crystal field and nephelauxetic effect on (NH<sub>4</sub>)<sub>2</sub>NaMF<sub>6</sub>: Mn<SUP>4+</SUP> (M = Al, Ga and In) red phosphors for warm white light-emitting diodes

Adjusting luminescence properties of ZnAl2O4:Mn2+(Mn4+), Li+ phosphors through cation substitution

Color-adjustable Fluorescence and Red Persistent Luminescence of Rare Earth-Free CaAlSiN3:Mn2+ Phosphors Prepared by Combustion Synthesis

Enhanced luminescence in SrMgAl(x)O(17±δ):yMn4+ composite phosphors.

Cs2MnF6 Red Phosphor with Ultrahigh Absorption Efficiency

Enhanced Luminescence Performances of Tunable Lu3-xYxAl5O12:Mn4+ Red Phosphor by Ions of Rn+ (Li+, Na+, Ca2+, Mg2+, Sr2+, Sc3+)

Luminescence properties of Eu3+‐doped MgAl2O4 nanopowders synthesized by micro‐emulsion method

Luminescence properties, crystal field and nephelauxetic effect on (NH4)2NaMF6: Mn4+ (M = Al, Ga and In) red phosphors for warm white light-emitting diodes

A Novel Al3+ Modified Li6CaLa2Sb2O12:Mn4+ Far-Red-emitting Phosphor with Garnet Structure for Plant Cultivation

Red-Emitting Ca9al(Po4)(7):Ce3+,Mn2+ Phosphor With Energy Transfer Prepared By Solid State Reaction

Broad Red Emission with Ultraviolet Excitation in Pr3+ Doped MgAl2O4 Phosphors