Abstract:This article proposes a three-dimensional heterogenous-integrated (3DHI) switchable bandpass filter bank with two independent wideband filter channels that cover 26-40 GHz and 32.5-40 GHz, respectively. An accurate wafer-level process with a high hollowed ratio of the applied 8-inch high-resistivity-silicon (HR-Si) interposer wafers is presented to form both compact filter channels. Above the interdigital filter patterns fabricated on the bottom interposer wafer, deep cavities are etched in the cap interposer wafer to improve the quality factor of the filter bank. Besides the cavities, the cap interposer wafer is 35% hollow inside, which two bare dies of GaAs single-pole double-throw (SPDT) switches and two thin film resistors are attached to the bottom interposer after the wafer-to-wafer (W2W) bonding. To ensure good out-of-band performance, a 3D EM co-simulation of the switch layout at the chip level and filter patterns at the package level is applied. Measurement results show that the switchable filter bank achieves a high isolation of 50 dB and a competitive shape factor (BW30dB/BW3dB) of about 1.3. In addition, the size of the switchable filter bank is only 7.0 mm x 3.5 mm x 0.6 mm, and the weight is only 0.1 g.

Design of Compact On-Chip Filter Based on Half Mode Substrate Integrated Waveguide

Extended Doublet Bandpass Filters Implemented with Microstrip Resonator and Full-/Half-Mode Substrate Integrated Cavities

Design of a Miniaturized Dual-Band Double-Folded Substrate Integrated Waveguide Bandpass Filter with Controllable Bandwidths

Half Mode Substrate Integrated Waveguide (HMSIW) Bandpass Filter

Compact Substrate Integrated Waveguide (SIW) Transversal Filter with Triple-Mode Microstrip Resonator

Substrate-Integrated Waveguide Bandpass Filters with Planar Resonators for System-on-Package

Miniaturized Dual-Band Substrate Integrated Waveguide Filter with Controllable Bandwidths

Ultra‐wideband Bandpass Filter Using Half‐mode T‐septum Substrate Integrated Waveguide with Electromagnetic Bandgap Structures

3D Heterogenous Integrated Wideband Switchable Bandpass Filter Bank for Millimeter Wave Applications

Compact Single- and Dual-Band Filters on Hexa-Modes Half-Mode Substrate Integrated Waveguide Resonator With Loaded H-Shaped Slot

Substrate Integrated Waveguide Filter with Flat Passband Based on Complex Couplings

Compact Coplanar Waveguide-Incorporated Substrate Integrated Waveguide (SIW) Filter

Broadband Filter Based on Stub-Loaded Ridge Substrate Integrated Waveguide (SIW) in Low Temperature Cofired Ceramic (LTCC)

Compact quasi-elliptic bandpass filter based on folded ridge substrate integrated waveguide (FRSIW)

Miniaturized and High-Selectivity Substrate Integrated Waveguide (SIW) Bandpass Filter Loaded by Complementary Split-Ring Resonators (Csrrs)

Compact Dual‐layer Substrate‐integrated Waveguide Bandpass Filters with Controllable Transmission Zeros

Compact half-mode SIW bandpass filter with high-frequency selectivity

A Band-Pass Filter Based on Half-Mode Substrate Integrated Waveguide and Spoof Surface Plasmon Polaritons

Narrowband HMSIW-SSPP Hybrid Bandpass Filter Operating at Millimeter-wave Band

Miniaturized Half-Mode T-Septum SIW Bandpass Filter With an Ultrawide Stopband

Miniaturized half‐mode SIW band‐pass filter design integrating dumbbell DGS cells