Abstract:Spray cooling features with high heat flux and good temperature control ability, which has been widely used in industrial environments such as electronic devices and nuclear power plants. In this study, the transient process of droplet-wall collision under film and transition boiling conditions has been investigated experimentally via the high-speed shadowgraph imaging and state-of-the-art image processing techniques. Based on intensive test conditions, the impact morphology, number, size, trajectory, ejecting angle and velocity of secondary droplets are presented and analyzed comprehensively. In experiments, distilled water was the test fluid, with initial droplets at 3 ± 0.03 mm. Droplet collision velocity was calculated based on the center distance in two pre-collision frames. The Weber number changes from 15.4 to 104.2, while the wall temperature varies from 307.6 °C to 511.8 °C. The observed collision phenomena can be divided into four types, including rebound, rebound with secondary atomization, breakup with secondary atomization, and breakup. An Improved Cascade Gaussian Fitting method (ICGF), which performs well in the dense and mutually occlusive areas, is adopted for particle identification. The statistical results show that the secondary droplet diameter mainly distributes in the range of 0.02 mm to 0.2 mm under different Weber numbers. Under similar wall temperature conditions, the number of secondary droplets and the average diameter of secondary droplets increase with Weber number. Moreover, the separation mass ratio increased from 0.18 % to 2.29 %. Specifically, it is found that the amount and size of secondary droplets decrease significantly when the boiling mode transfers from transition to film. Based on the time-resolved shadowgraph images, a four-frame optimal estimation particle tracking algorithm is used to obtain the two-dimensional trajectory of the secondary droplets. The measured velocity distributes in the range of 0.3 m/s-4.0 m/s, mainly concentrating in the range of 0.5 m/s-2.0 m/s. The number and size variation with time is also analyzed, which indicates most of the secondary droplets are generated due to the strong instability in the transition boiling states.

Experimental Investigation of Droplet Propulsion Driven by Thermal Power Conversion

Droplet Evaporation to Boiling in Van Der Waals Fluid

Leidenfrost droplet jet engine by bubble ejection

Experimental and Theoretical Study on the Ceasing Motion of a Droplet Manipulated by Air-Blowing Nozzle

Experimental study of two-phase heat transfer of droplet impact on liquid film

Dynamic characteristics of droplet impact on heated surfaces near Leidenfrost temperature

Synthesis of Scalable Micro-Droplets with Heat-Driven Effect in Flow-Focusing Device.

Universal droplet propulsion by dynamic surface-charge wetting

Interfacial heat transfer and boiling transition of the droplets on superheated surface with Leidenfrost effects

Experimental Investigation of Velocity and Temperature Distribution Inside Single Droplet Impingement on a Heated Substrate

Droplet boiling on heated surfaces with various wettabilities

Dynamics of a Leidenfrost Droplet Modulated by Electrowetting

Microdroplet self-propulsion during dropwise condensation on lubricant-infused surfaces

Dynamics and Heat Transfer of Water Droplets Impacting on Heated Surfaces: the Role of Surface Structures in Leidenfrost Point

Dynamic Behavior of Droplet Impact on Laminar Superheated Particles

Self-propelled Droplet Behavior During Condensation on Superhydrophobic Surfaces

Experimental and Numerical Investigations on Flash Evaporation of a Sessile Droplet under Reduced Pressure

Elevating Leidenfrost temperature by orderly droplet stream impingement boiling

Numerical investigation of Weber number and gravity effects on fluid flow and heat transfer of successive droplets impacting liquid film

Experimental Study on the Dynamic Behaviors and Spreading Characteristics of a Liquid Nitrogen Droplet Impacting Superheated Wall

Final Fate of a Leidenfrost Droplet: Explosion or Takeoff