Abstract:The biological oxidation of elemental sulfur (S 0 ) to sulfate and the reduction of S 0 to sulfide provide a potential route for extracting and reclaiming phosphorus (P) from anaerobically digested sludge (ADS). However, the treatment performance, stability, and cost-effectiveness of the two opposing bioprocesses based on S° for selective P recovery from ADS remain unclear. This study aimed to compare the roles of S 0 -oxidizing bacteria (S 0 OB) and S 0 -reducing bacteria (S 0 RB) in liberating insoluble P from ADS through single-batch and consecutive multibatch experiments. Changes in P speciation in the sludge during the biological extraction processes were analyzed by using complementary sequential extraction and P X-ray absorption near-edge spectroscopy. Results showed that S 0 OB treatment extracted more phosphate from the sludge compared with S 0 RB treatment, but it also released a considerable amount of metal cations (e.g., heavy metals, Mg 2+ , Al 3+ , Ca 2+ ) and negatively affected sludge dewaterability due to intense sludge acidification and cell lysis. At pH 1.2, the S 0 OB treatment released 92.9% of P from the sludge, with the dissolution of HAP, Fe-PO 4 , Mg 3 (PO 4 ) 2 , and P-fehrrihy contributing 26.8%, 22.1%, 12.8%, and 10.5%, respectively. The S 0 RB treatment released 63.6% of P from the sludge at pH 7.0, with negligible dissolution of metal cations, thereby avoiding costly purification of the extract and alkali neutralization for pH adjustment. This treatment involved the replacement of phosphates bounded with Fe-PO 4 (FePO 4 and P-fehrrihy) and Al–PO 4 (P-Alumina and AlPO 4 ) with biogenic sulfides, with contributions of 72.7%, and 20.9%, respectively. Consecutive bioprocesses for P extraction were achieved by recirculating the treated sludge. Both S 0 OB and S 0 RB treatments did not affect the extent of sludge dewatering but considerably weakened the dewatering rate. The S 0 OB-treated sludge exhibited prolonged filtration time (from 3010 s to 9150 s) and expressing time (from 795 s to 4690 s) during compression dewatering. After removing metal cations using cation exchange resin (CER) and neutralizing using NaOH, a vivianite product Fe 3 (PO 4 ) 2 ·8H 2 O (purity: 84%) was harvested from the S 0 OB-treated extract through precipitation with FeSO 4 ·7H 2 O. By contrast, a vivianite product Fe 3 (PO 4 ) 2 ·8H 2 O (purity: 81%) was directly obtained from the S 0 RB-treated extract through precipitation with FeSO 4 ·7H 2 O. Ultimately, 79.8 and 57.9wt% of P were recovered from ADS through S 0 OB extraction–CER purification–alkali neutralization–vivianite crystallization, and S 0 RB extraction–vivianite crystallization, respectively. Collectively, biological S 0 reduction is more applicable than biological S 0 oxidation for selectively reclaiming P from Fe/Al-associated phosphate-rich ADS due to better cost-effectiveness and process simplicity. These findings are of significance for developing sludge management strategies to improve P reclamation with minimal process inputs.

New Insights into the Microbial-Driven Metal Reductive Dissolution for Enhanced Phosphorus Release from Iron-Rich Sludge

Organic Matter Accelerated Microbial Iron Reduction and Available Phosphorus Release in Reflooded Paddy Soils

Acidogenic Phosphorus Recovery from the Wastewater Sludge of the Membrane Bioreactor Systems with Different Iron-Dosing Modes.

Remove and Recover Phosphorus During Anaerobic Digestion of Excess Sludge by Adding Waste Iron Scrap

Phosphorus recovery from sludge by rusty scrap iron enhanced anaerobic digestion and vivianite crystallization

Recovery of Phosphorus from Wastewater and Sludge

Mechanisms governing the dissolution of phosphorus and iron in sewage sludge by the bioacidification process and its correlation with iron phosphate speciation

A novel approach using protein-rich biomass as co-fermentation substrates to enhance phosphorus recovery from FePs-bearing sludge

A Membrane Bioreactor with Iron Dosing and Acidogenic Co-Fermentation for Enhanced Phosphorus Removal and Recovery in Wastewater Treatment

Changes of phosphorus species during (hydro) thermal treatments of iron-rich sludge and their solubilization mediated by a phosphate solubilizing microorganism

Enrichment of Phosphate on Ferrous Iron Phases during Bio-Reduction of Ferrihydrite

Simultaneous enhancing phosphorus recovery and volatile fatty acids production during anaerobic fermentation of sewage sludge with peroxydisulfate pre-oxidation

Transformation and migration of phosphorus in excess sludge reduction pretreatment by alkaline ferrate oxidation combined with anaerobic digestion

Carbon source and phosphorus recovery from iron-enhanced primary sludge via anaerobic fermentation and sulfate reduction: Performance and future application

A comparative study of different iron minerals on phosphorus capture from municipal wastewater and subsequent recovery as vivianite through acidogenic fermentation

Elemental sulfur redox bioconversion for selective recovery of phosphorus from Fe/Al-bound phosphate-rich anaerobically digested sludge: Sulfur oxidation or sulfur reduction?

A new and efficient approach for phosphorus recovery from wastewater in the form of vivianite mediated by iron-reducing bacteria

Effect of iron sources on methane production and phosphorous transformation in an anaerobic digestion system of waste activated sludge

Enhanced reduction of sulfate by iron-carbon microelectrolysis: interaction mechanism between microelectrolysis and microorganisms

Clarification of the phosphorus release mechanism for recovering phosphorus from biofilm sludge in alternating aerobic/anaerobic biofilm system

Targeting Phosphorus Transformation to Hydroxyapatite Through Sewage Sludge Pyrolysis Boosted by Quicklime Toward Phosphorus Fertilizer Alternative with Toxic Metals Compromised